Please read this manual BEFORE
installing and operating this
appliance.
3
This appliance has been professionally installed by:
Dealer Name: ________________________________
Phone:______________________________________
Welcome to Valor
®
Fireplace Safety ................................................. 4
Specifi cations ..................................................... 6
Kits & Accessories .............................................. 7
Dimensions & Location ..................................... 8
Planning .............................................................. 9
Before Installing ............................................................9
Overview ......................................................................10
Combustible Clearances ............................................11
Framing .........................................................................13
Stud Framing ...............................................................13
Hearth ..........................................................................14
Venting Considerations When Framing ..................18
Appliance Height in Framing ....................................19
Appliance Depth in Framing .....................................19
Using 1430FFK—Fixed Framing Kit ..........................20
Using 1430CIK—Clean Install Kit .............................22
Using 3 or 4-Sided Trims ...........................................24
Wall Finish ................................................................... 26
Non-Combustible Board ...........................................26
Finishing Around Trims .............................................26
Cracking Wall Finishes ...............................................27
Venting .............................................................. 28
Overview ..................................................................... 28
Typical Venting Components ................................... 29
Venting Chart .............................................................. 30
Venting Diagram ........................................................ 31
Res tric tors ................................................................... 32
Horizontal Vent Termination.................................... 33
Vertical Vent Termination ......................................... 3 4
Preparation ...................................................... 35
Stand-off s & Heat Shield .......................................... 35
Vent Take-Off .............................................................. 36
Window Removal & Reinstallatio n .......................... 37
Optional Heat Shif t ..................................................... 4 0
Remove Convection Baffle ...................................... 40
Install HeatShift Take-Off Collars ........................... 40
Installation ....................................................... 41
Electrical Wiring ..........................................................41
With 1430FFK—Fixed Framing Kit ........................... 42
With 1430CIK—Clean Install Kit ............................... 44
With 3 or 4-Sided Trims ............................................. 47
Gas Supply ................................................................... 48
Liners ........................................................................... 49
Fuel Beds ......................................................................51
Birch Logs 1400BLK ...................................................51
Driftwood 1400DWKV2 ............................................ 54
Traditional Logs 1400LSKV2 .....................................57
Remote Battery and Wall Switch ............................. 60
Remote Control Set-Up ............................................. 62
Decorative Lighting .................................................... 63
Check Operation and Burner Aeration .................. 64
Trim and Barrier Screen ............................................ 64
Wiring Diagram ................................................ 65
Approved Venting Components .................... 66
Commonwealth of Massachusetts ............... 68
Appendix A - Lighting Instructions Plate ...... 70
Appendix B - Remote Control Operation ..... 71
Appendix C - Wall Switch Operation ............. 78
Appendix D - HeatShift System ..................... 79
Appendix E - Spare Parts ................................ 99
To Next Page
Loading...
