American-Lincoln 1-29
MPV 60
SERVICE CHART
EVERY 8 HOURS or DAILY operation check and clean/adjust if necessary:
1. Inspect panel filter for damage and clean.
2. Check engine oil level
3. Check hydraulic fluid level
4. Check radiator cooling fins for blockage
5. Check all flaps for wear or damage
6. Check brooms for wear or damage, adjust as required
7. Check brake pedal and parking brake
8. Clean engine air filter dust cap and check filter
9. Check hydraulic oil filter
10. Check coolant level
11. Check LP connections for odor.
EVERY 50 HOURS
12. Check tension on all belts
13. Check battery electrolyte level
14. Lubricate dump system
15.Check all hydraulic hoses for wear or cuts
16. Rotate main broom (end for end)
17. Clean or replace panel filters
18. Perform recommended engine maintenance (See engine manual)
EVERY 100 HOURS
19. Change crankcase oil.
20. Change engine oil filter.
21. Check fuel hose for leaks or deterioration.
22. Check radiator hoses and clamps.
23. Lubricate steering yoke pivot bearings.
24. Lubricate front wheel bearings.
25. Lubricate all moving joints.
26. Check brake pads for wear and adjustment.
27. Lubricate all 4 “DANHOUSER” bushings with NAPA #765-1363 (or equivalent) anti-seize lubricant.
The bushings are located on the steering , hopper lift, and dump door cylinders.
28. Perform recommended engine maintenance (See engine manual)
EVERY 250 HOURS
29. Replace engine air filter element
30.Flush radiator coolant system
31. Remove spark plugs - clean or replace
32. Clean and lubricate governor linkage (Diesel)
33. Replace fuel filter
34. Replace hydraulic filter element
35. Perform recommended engine maintenance (See engine manual)
EVERY 500 HOURS
36. Clean hydraulic reservoir
37. Clean hydraulic intake strainer
38. Change hydraulic fluid
39. Perform recommended engine maintenance (See engine manual)
Refer all Maintenance and Service Requirements to Qualified Maintenance Personnel.
To Next Page
Loading...
