Buderus Logamax plus - Inspection Report

Reports15
Logamax plus GB162-80 kW/100 kW - Subject to modifications resulting from technical improvements!86
15.2 Inspection report
z Indicate the inspection activities that have been carried
out, enter the values measured and enter your signature
and the date.
Inspection activities see paragraph
Date:
______
Date:
______
Date:
______
Date:
______
Date:
______
Date:
______
Date:
______
1. Check the general condition of the
heating system
2. Carry out a visual inspection and
function test of the heating system
3. Checking the gas and water-
bearing system components for:
- Operational tightness 9.9 on page 54
- Visible corrosion 11.2 on page 63
- Signs of wear
- Fill the condensate trap 9.3 on page 48
4. Measure the ionization current 9.12 on page 56
_____ µA _____ µA _____ µA _____ µA _____ µA _____ µA _____ µA
5. Measure the gas inlet pressure
(working pressure)
9.7 on page 50
____
inch W.C.
____
inch W.C.
____
inch W.C.
____
inch W.C.
____
inch W.C.
____
inch W.C.
____
inch W.C.
6. Check and adjust the gas/air ratio 9.8 on page 52
________
inch W.C.
________
inch W.C.
________
inch W.C.
________
inch W.C.
________
inch W.C.
________
inch W.C.
________
inch W.C.
7. Carry out a leakage test in
operating conditions
9.9 on page 54
8. Measure the flue gases CO
emissions
9.10 on page 55
____ ppm ____ ppm ____ ppm ____ ppm ____ ppm ____ ppm ____ ppm
9. Fill the heating system
– Pre-pressure of expansion
vessel (also see installation
instructions for expansion
vessel)
_____ psi _____ psi _____ psi _____ psi _____ psi _____ psi _____ psi
– Filling pressure 9.2 on page 47
_____ psi _____ psi _____ psi _____ psi _____ psi _____ psi _____ psi
10. Check the air/flue gas connection 9.5 on page 49
11. Checking the boiler settings of the
control device (in accordance with
requirements)
documents for the
control device.
12. Final check of the inspection
activities, documenting the
measurement and test results
13. Confirming proper inspection
Company
stamp/
signature
Company
stamp/
signature
Company
stamp/
signature
Company
stamp/
signature
Company
stamp/
signature
Company
stamp/
signature
Company
stamp/
signature