CSC RX3 - Maintenance Cautions and Warnings

CSCRX3ServiceManual
www.CSCMotorcycles.com
5

MaintenanceCautionsandWarnings

Whenyourepair  the motorcycle,pleaseuseoriginalcomponentsandparts,accessories, lubricatingoil
and other materials that are made or recognized by CSC Motorcycles.If you use any parts  or
components which are not recognized or recommended by our company, it may adversely affect the
performance,
reliability,orstabilityofyourmotorcycle.

Whenworkingonyourmotorcycle,youshouldfollowthisguidance:

 Whenever the motorcycle is to be reassembled after disassembly, washers, seals, and cotter
pinsneedtobereplaced.
 Whenyoufastenaboltoranut,youshoulddoitina
diagonalpattern.
 Donotuseflammablecleaningfluidtocleancomponentsandparts.
 Beforeassemblyoperations,addlubricatingoilorlubricatinggreasetolubricatedsurfaces.
 Afterassembly,makesureallpartsareproperlyassembledandtightened.
 Stoptheenginewhenrepairingthemotorcycle.
 Ifthe
maintenanceoperationneedstobedonewhiletheengineisworking,makesurethearea
iswell‐ventilated.
 Gasisflammableandcombustible,sodonotsmokeorprovideignitionsourcesintheworkarea.
 The battery can liberate hydrogen, which is flammable. Do not smoke, ignite or make
 sparks
nearthebattery,especiallywhenitischarging.
 The electrolyte of the battery contains sulfuric acid.  If your eyes, skin or clothes are splashed
withelectrolyte,rinsethemthoroughlywith waterandseekimmediatemedicalattention.

Themeaningsofthesymbolsinthismanualareasfollows:

Warning

◆ Potentialdanger.Improperoperationmayleadtoinjuryordeath.

Caution

◆ Potentialdanger.Improperoperationmayleadtomotorcycledamage.

PartsandComponentsCleaning

Afterpartsaredisassembled,theymayneedtobecleaned.Cleaningmethodsvaryaccordingtothe
characteristicsoftheparts.

 Toremoveoilorgreasecontamination,CSCrecommendsusingSimpleGreenorother
similar
degreasingagents.
 Neverusegasolineasacleaningagent.
 Toremovecarbondeposits,usemechanicalorchemicalmethods.Themechanicalmethoduses
awoodenorplasticscraperorbladetoclearthecarbondepositfirst,andthenrinsetheparts
withanappropriatecleaningagent.Thechemical
methodistosoakthepartsinthecleaning