Dodge 2000 DURANGO - Body Component Service

BODY COMPONENT SERVICE
TABLE OF CONTENTS
page page
DESCRIPTION AND OPERATION
BODY COMPONENTS .....................19
INTERIOR TRIM PANELS...................19
DIAGNOSIS AND TESTING
WATER LEAKS ..........................19
SERVICE PROCEDURES
BODY LUBRICATION ......................20
HEAT STAKING ..........................20
REMOVAL AND INSTALLATION
GRILLE ................................21
HOOD .................................21
HOOD SILENCER PAD ....................22
HOOD HINGE ...........................22
HOOD SAFETY LATCH ....................22
HOOD LATCH STRIKER....................22
HOOD LATCH ...........................23
HOOD RELEASE CABLE ...................23
COWL GRILLE ...........................24
COWL SEAL ............................24
HOOD SEAL ............................25
FRONT WHEELHOUSE LINER...............25
LEFT FRONT FENDER.....................26
RIGHT FRONT FENDER ...................26
RUNNING BOARD ........................28
EXTERIOR NAMEPLATES ..................28
DECALS................................30
SIDE VIEW MIRROR ......................30
FRONT DOOR TRIM PANEL ................31
FRONT DOOR WATERDAM .................31
FRONT DOOR ...........................32
FRONT DOOR HINGE .....................33
FRONT DOOR OUTSIDE HANDLE............33
FRONT DOOR LOCK CYLINDER .............33
LOCK CYLINDERS........................35
FRONT DOOR LATCH .....................35
FRONT DOOR LATCH STRIKER .............35
FRONT DOOR INSIDE HANDLE ACTUATOR ....35
FRONT DOOR INNER BELT WEATHERSTRIP . . . 36
FRONT DOOR OUTER BELT WEATHERSTRIP . . 36
FRONT DOOR GLASS .....................36
FRONT DOOR WINDOW REGULATOR ........37
FRONT DOOR LOWER GLASS RUN
CHANNELS............................37
FRONT DOOR GLASS RUN WEATHERSTRIP . . . 38
FRONT DOOR OPENING WEATHERSTRIP .....38
FRONT DOOR SECONDARY SEAL ...........38
REAR DOOR TRIM PANEL..................38
REAR DOOR WATERDAM ..................40
REAR DOOR............................40
REAR DOOR HINGE ......................40
REAR DOOR OUTSIDE HANDLE.............40
REAR DOOR LATCH ......................41
REAR DOOR LATCH STRIKER ..............41
REAR DOOR INSIDE HANDLE ACTUATOR .....42
REAR DOOR INNER BELT WEATHERSTRIP ....42
REAR DOOR OUTER BELT WEATHERSTRIP . . . 42
REAR DOOR OPENING WEATHERSTRIP ......42
REAR DOOR WINDOW REGULATOR .........42
REAR DOOR GLASS RUN WEATHERSTRIP ....43
REAR DOOR GLASS RUN CHANNELS ........44
REAR DOOR GLASS ......................44
C—PILLAR SEAL .........................44
REAR DOOR SECONDARY SEAL ............45
ROOF RAIL WEATHERSTRIP AND RETAINER. . . 45
BODY SIDE MOLDINGS....................45
WHEEL OPENING MOLDING................46
FUEL FILLER DOOR ......................47
REAR WHEEL HOUSE LINER ...............47
LIFTGATE TRIM PANEL ....................47
LIFTGATE HINGE.........................48
LIFTGATE SUPPORT CYLINDER .............48
LIFTGATE ..............................49
LIFTGATE OUTSIDE HANDLE ...............49
LIFTGATE LOCK CYLINDER ................49
LIFTGATE LATCH ........................50
LIFTGATE LATCH STRIKER.................50
LIFTGATE OPENING WEATHERSTRIP ........50
LIFTGATE MOLDING ......................51
LUGGAGE RACK .........................51
COWL TRIM COVER ......................52
A-PILLAR GRAB HANDLE ..................52
A-PILLAR TRIM ..........................52
DOOR SILL TRIM.........................52
B-PILLAR TRIM ..........................53
C-PILLAR TRIM ..........................53
LIFTGATE OPENING UPPER TRIM ...........53
D-PILLAR TRIM ..........................54
QUARTER PANEL TRIM....................55
LIFTGATE SCUFF PLATE...................56
FRONT SEAT BELT RETRACTOR ............56
FRONT SEAT BELT BUCKLE ................57
2ND ROW SEAT BELT RETRACTOR ..........57
2ND ROW SEAT BELT BUCKLE..............57
3RD ROW SEAT BELT RETRACTOR ..........57
3RD ROW SEAT BELT BUCKLE..............59
BUCKET SEAT...........................59
2NDROWSEAT .........................61
3RDROWSEAT .........................61
23 - 18 BODY DN