53
Note-9 : Replace the pinion starter assembly once in every 2 years or 21000 km, whichever is earlier.
Perform the pre-ride inspection (page 42) at each scheduled maintenance period.
Note-2 : Throttle play to be checked and adjusted as per given specification
Note-12: Inspect for any play in the rear suspension mounting bushes, replace if necessary.
E: EMISSION CHECK
MAINTENANCE SCHEDULE
To be serviced by your Authorised Hero MotoCorp workshop unless the owner
has the relevant tools, technical information and is technically qualified.
In the interest of safety, we recommend that these jobs are carried out only by
your Authorised Hero MotoCorp workshop.
Note-5 : Replace once in every 12000 km.
Note-6 : Replace engine oil once in every 6000 km. Top up if the oil level is at or near the lower level
mark.
Note-10 : Replace drive belt once in every 24000 km.
*Replace at any point of time, if pre foam and viscous element found damage.
Note-15: Inspect the canister hoses for deterioration, damage or loose connections and canister for cracks
or other damages.
Ensure that each paid service is availed within 90 days or 3000 km from the date of previous service,
whichever is earlier.
Note-1 : At higher odometer readings, repeat the frequency interval established here.
The following maintenance schedule specifies all maintenance required to keep your vehicle in peak operating
condition. Maintenance work should be performed in accordance with standards and specifications of Hero
MotoCorp by properly trained and equipped technicians. Your Authorised Hero MotoCorp workshop
meets all of these requirements.
Note-8 : Replace once in every two years or 30000 km, whichever is earlier.
Note-7 : Replace once in every 10000 km or once in a year, whichever is earlier. Replacement requires
mechanical skill.
*At 12000 km inspect if air cleaner element (viscous type) is choked. If found choked, replace
the air cleaner element to keep the engine healthy.
Note-3 : Replace air cleaner element once in every 15000 km or early replacement may be required
when riding in dusty areas.
Note-11: Replace front fork oil once in a every 2 years or 20000 km, whichever is earlier.
Note-13: Inspect the bearings free play, replace if necessary.
Note-14: Check CO emission at idle.
I: INSPECT C: CLEAN R: REPLACE A: ADJUST L:LUBRICATE T: TOP UP
Note-4 : Service more frequently when riding in rain or at full throttle.
To Next Page
Loading...
