Isuzu D-MAX 2020 - Page 819

6-143
SERVICE AND MAINTENANCE
Maintenance Schedule: TFR/S 87 (RZ4E-TCX) models for the European,
Israel,Turkey,HongKongandSingaporemarkets
I : Inspect then clean, adjust, repair, or replace as necessary A: Adjust R: Replace
T: Tighten to the specified torque L: Lubricate
Service item
Service
content
Serviceinterval(Odometerreadingormonths,
whichever comes first)
Reference
page
*Engineoil R Every 20,000 km (12,000 miles) or 24 months 6-22
*Engineoilfilter R Every 20,000 km (12,000 miles) or 24 months 6-28
Engineoilleakageand
contamination
I Every 20,000 km (12,000 miles) or 24 months 6-22
Engineidlingspeedand
acceleration
I Every 20,000 km (12,000 miles) or 24 months 6-21
Accessory belt tension and
damage
I Every 20,000 km (12,000 miles) or 24 months 6-50
Exhaust system I Every 20,000 km (12,000 miles) or 24 months ―
All hoses and pipes in
enginecompartmentfor
clogordamage
I Every 20,000 km (12,000 miles) or 24 months ―
* Air cleaner element
I
R
Every 20,000 km (12,000 miles) or 24 months
Every 40,000 km (24,000 miles) or 48 months
6-51
Fuel filter R
Replace the fuel filter when the fuel filter
warninglightcomeson
4-65
6-53
Fuel tank I Every 20,000 km (12,000 miles) or 24 months ―
Fuel hoses and pipes for
clogordamage
I Every 20,000 km (12,000 miles) or 24 months ―
Drainingofwaterseparator
Drainthefuelfilterwhenthewaterseparatorwarninglight
comes on
4-65
6-54
Enginecoolant/intercooler
coolant concentration
I Every 20,000 km (12,000 miles) or 24 months
6-37
6-45
Enginecoolant/
intercooler coolant
R
Initial 160,000 km (96,000 miles) or 96 months
6-36
6-43
Every 160,000 km (96,000 miles) or 96 months
(whenIsuzugenuinecoolantisused)
6-36
6-43
Every 24 months
(when Isuzu recommended coolant is used)
6-36
6-43
Coolingsystemforwater
leakage
I Every 20,000 km (12,000 miles) or 24 months
6-39
6-47
Clutch pedal travel and
play
I Every 20,000 km (12,000 miles) or 24 months ―
* [M/T] Manual
transmission oil and oil
leakage
I
R
Every 20,000 km (12,000 miles) or 24 months
Every 40,000 km (24,000 miles) or 48 months
―
* [4WD] Transfer case oil
andoilleakage
I Every 20,000 km (12,000 miles) or 24 months ―
Gear control mechanism
for looseness
I Every 20,000 km (12,000 miles) or 24 months ―
*Marks:Underseveredrivingconditions,additionalmaintenanceisrequired.
Referto"MaintenanceScheduleforSevere-conditionOperations".
5108428_sec06_SERVICE AND MAINTENANCE_P141-end.indd 143 2020/11/16 9:22:04