Jungheinrich KMS 100 User Manual

1298.GB
I 2
E Operation
1 Safety regulations governing the operation of the truck ...................... E 1
2 Operating panel arrangement variants ................................................ E 2
3 Description of controls and indicating instruments .............................. E 4
3.1 Operating controls and displays at the instrument panel .................... E 4
3.2 Operating controls and indications at the Display .............................. E 5
3.3 Symbols indicating the truck’s operating status .................................. E 6
4 Putting vehicle in operation ................................................................. E 7
5 Working with the truck ......................................................................... E 8
5.1 Safety regulations for operating mode Drive ....................................... E 8
5.2 Driving, steering, braking .................................................................... E 9
5.3 Lifting and lowering outside and inside the shelf aisles ...................... E 14
5.4 Combined driving (simultaneous driving and lifting). ........................... E 15
5.5 Commissioning and stacking .............................................................. E 16
5.6 Safe parking of the truck ..................................................................... E 17
6 Fault location ....................................................................................... E 18
6.1 Emergency-STOP ............................................................................... E 19
6.2 Emergency lowering of driver’s cabin ................................................. E 19
6.3 Leaving the driver’s cabin using the emergency rope-down facility .... E 20
6.4 Slack chain protection (acknowledge signal) ...................................... E 21
6.5 Drive switch-off (o) ............................................................................. E 21
6.6 Lift switch-off (o) ................................................................................. E 21
6.7 End of aisle safety device (o).............................................................. E 22
6.8 IG emergency operation ...................................................................... E 23
6.9 Recovering the truck from a narrow aisle ............................................ E 24
1298.GB
I 2
E Operation
1 Safety regulations governing the operation of the truck ...................... E 1
2 Operating panel arrangement variants ................................................ E 2
3 Description of controls and indicating instruments .............................. E 4
3.1 Operating controls and displays at the instrument panel .................... E 4
3.2 Operating controls and indications at the Display .............................. E 5
3.3 Symbols indicating the truck’s operating status .................................. E 6
4 Putting vehicle in operation ................................................................. E 7
5 Working with the truck ......................................................................... E 8
5.1 Safety regulations for operating mode Drive ....................................... E 8
5.2 Driving, steering, braking .................................................................... E 9
5.3 Lifting and lowering outside and inside the shelf aisles ...................... E 14
5.4 Combined driving (simultaneous driving and lifting). ........................... E 15
5.5 Commissioning and stacking .............................................................. E 16
5.6 Safe parking of the truck ..................................................................... E 17
6 Fault location ....................................................................................... E 18
6.1 Emergency-STOP ............................................................................... E 19
6.2 Emergency lowering of driver’s cabin ................................................. E 19
6.3 Leaving the driver’s cabin using the emergency rope-down facility .... E 20
6.4 Slack chain protection (acknowledge signal) ...................................... E 21
6.5 Drive switch-off (o) ............................................................................. E 21
6.6 Lift switch-off (o) ................................................................................. E 21
6.7 End of aisle safety device (o).............................................................. E 22
6.8 IG emergency operation ...................................................................... E 23
6.9 Recovering the truck from a narrow aisle ............................................ E 24

Jungheinrich KMS 100 Specifications

General

Brand	Jungheinrich
Model	KMS 100
Category	Forklifts
Language	English