SERVICE SCHEDULE 9
39
9.1 Additional information
Any further work that results from the compulsory work or from the recommended work must be ordered sepa-
rately and invoiced separately.
Different service intervals may apply in your country, depending on the local operating conditions.
Individual service intervals and scopes may change in the course of technical developments. The most up-to-date
service schedule can always be found on KTM Dealer.net. Your authorized KTM dealer will be happy to advise
you.
9.2 Required work
every 24 months
every 12 months
every 20,000 km (12,400 mi)
every 10,000 km (6,200 mi)
after 1,000 km (620 mi)
Read out the fault memory using the KTM diagnostics tool. ○ ● ● ● ●
Program the shift shaft sensor. ○ ● ● ● ●
Check that the electrical system is functioning properly. ○ ● ● ● ●
Change the engine oil and the oil filter, clean the oil screens. ( p. 97) ○ ● ● ● ●
Check the front brake linings. ( p. 65) ○ ● ● ● ●
Check the rear brake linings. ( p. 68) ○ ● ● ● ●
Check the brake discs. ( p. 63) ○ ● ● ● ●
Check the brake lines for damage and tightness. ○ ● ● ● ●
Change the front brake fluid. ●
Change the rear brake fluid. ●
Change the hydraulic clutch fluid. ●
Check the front brake fluid level. ( p. 63) ○ ● ● ●
Check the rear brake fluid level. ( p. 66) ○ ● ● ●
Check/correct the fluid level of hydraulic clutch. ( p. 59) ● ● ●
Check the free travel of the foot brake lever. ( p. 65) ○ ● ● ● ●
Check the shock absorber and fork for leaks. Perform a fork service and shock absorber
service as needed and depending on how the vehicle is used.
○ ● ● ● ●
Clean the dust boots of the fork legs. ( p. 48) ● ●
Check the steering head bearing play. ○ ● ● ● ●
Check the tire condition. ( p. 74) ○ ● ● ● ●
Check tire pressure. ( p. 76) ○ ● ● ● ●
Check the spoke tension. ( p. 77) ○ ● ● ● ●
Check for rim run-out. ○ ● ● ● ●
Check the chain, rear sprocket, engine sprocket, and chain guide. ( p. 56) ● ● ● ●
Check the chain tension. ( p. 55) ○ ● ● ● ●
Change the fuel screen. ○
Change the spark plugs. ●
Check the valve clearance. ● ●
Check the antifreeze and coolant level. ( p. 89) ○ ● ● ● ●
Check the cables for damage and for routing without kinks. ● ● ● ●
Change the air filter, clean the air filter box. ● ●
Change the fuel screen, check the fuel pressure. ● ● ● ●
To Next Page
Loading...
Need help?
General
