Perkins 5012C-E46TA - Page 102

F
Fan Drive Pulley - Check................................. 85
Fault Logging................................................... 43
Features and Controls..................................... 35
Fire Prevention and Explosion Prevention...... 17
Ether ............................................................ 18
Fire Extinguisher.......................................... 18
Lines, Tubes, and Hoses ............................. 19
Fluid Recommendations (Engine Oil
Specification) ................................................. 53
Engine Oil .................................................... 53
General Lubricant Information..................... 53
Fluid Recommendations (General Coolant
Information) ................................................... 50
General Coolant Information ....................... 50
Fluid Recommendations (General Fuel
Information) ................................................... 53
Refill Capacities for the Fuel System........... 53
Foreword ........................................................... 4
California Proposition 65 Warning................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 5
Operation ....................................................... 4
Overhaul ........................................................ 5
Safety............................................................. 4
Fuel and the Effect from Cold Weather........... 48
Fuel Conservation Practices ........................... 46
Fuel Injector - Inspect/Adjust........................... 86
Fuel Injector - Replace .................................... 86
Fuel Related Components in Cold Weather ... 48
Fuel Heaters ................................................ 48
Fuel Tanks ................................................... 48
Fuel System - Prime ........................................ 86
Fuel System Primary Filter - Replace ............. 87
Fuel System Primary Filter/Water
Separator - Drain ........................................... 88
Fuel System Secondary Filter - Replace ........ 88
Fuel Tank Water and Sediment - Drain ........... 89
Drain the Water and the Sediment .............. 89
Fuel Storage Tanks...................................... 90
Fuel Tank ..................................................... 89
Fuel Transfer Pump (Lift Pump) - Inspect ....... 90
G
General Hazard Information............................ 12
Containing Fluid Spillage............................. 14
Dispose of Waste Properly .......................... 16
Fluid Penetration ......................................... 14
Inhalation ..................................................... 15
Pressurized Air and Water........................... 14
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ....................... 14
H
Hoses and Clamps - Inspect/Replace............. 90
Clamps and V-Band Clamp Torques ........... 93
Clamps and V-Band Locations .................... 92
Replace the Hoses and the Clamps ............ 90
I
Important Safety Information............................. 2
J
Jacket Water Heater - Check (If Equipped) .... 93
L
Lifting and Storage .......................................... 29
M
Maintenance Interval Schedule....................... 57
Daily or Prior to Starting Stand-by Unit........ 57
Every 1500 Service Hours........................... 57
Every 2000 Service Hours........................... 57
Every 3000 Service Hours........................... 57
Every 4000 Service Hours........................... 57
Every 500 Service Hours or 2 Years or Prior to
Functional Load Test.................................. 57
Every 6000 Service Hours or 3 Years ......... 57
Every 7500 Service Hours........................... 57
Initial 250 Service Hours or 1 Year .............. 57
When Required............................................ 57
Maintenance Recommendations .................... 56
Maintenance Section....................................... 50
Model View Illustrations .................................. 22
Engine Views ............................................... 22
Radiator View .............................................. 25
Model Views .................................................... 22
Monitoring System........................................... 35
Critical Protection Override.......................... 35
Diagnostic .................................................... 36
Shutdown..................................................... 35
Shutdown Reset .......................................... 36
Standard Warning Outputs .......................... 36
Warning Alarm ............................................. 35
Mounting and Dismounting ............................. 19
102 M0163009
Index Section