Perkins 5012C-E46TA - Page 103

O
Operation Section............................................ 29
Overhaul (Major) ............................................. 94
Major Overhaul Information ......................... 94
Scheduling a Major Overhaul ...................... 94
Overhaul (Top End) ......................................... 94
Scheduling a Top End Overhaul .................. 94
Top End Overhaul Information..................... 95
P
Plate Locations and Film Locations ................ 27
Emission Label ............................................ 27
Product Identification Information ................... 27
Product Information Section............................ 22
Product Lifting ................................................. 29
Engine Only ................................................. 29
Radiator ....................................................... 32
Product Storage .............................................. 32
Condition for Storage................................... 32
Engine.......................................................... 32
R
Radiator - Clean .............................................. 95
Refill Capacities............................................... 50
Cooling System.......................................... 50
Fuel System................................................ 50
Lubrication System ................................... 50
S
Safety Messages............................................... 6
Do Not Step ................................................... 8
Electrocution.................................................. 9
Ether Warning.............................................. 10
Hot Fluid Under Pressure ............................ 10
Hot Surface.................................................... 9
Rotating Shaft Hand Crush Hazard ..............11
Universal Warning ......................................... 8
Warning labels Position Bank A .................... 7
Warning Labels Position Bank B ................... 8
Safety Section ................................................... 6
Self-Diagnostics .............................................. 43
Sensors and Electrical Components............... 36
Engine Electrical Components .................... 40
Engine Sensor Views .................................. 37
Severe Service Application ............................. 56
Environmental Factors................................. 56
Incorrect Maintenance Procedures ............. 56
Incorrect Operating Procedures .................. 56
Severe Service Application - Check................ 96
Environmental Factors................................. 96
Incorrect Maintenance Procedures ............. 96
Incorrect Operating Procedures .................. 96
Speed Sensor - Clean/Inspect ........................ 97
Speed Sensor .............................................. 97
Starting Motor - Inspect ................................... 97
Starting the Engine.......................................... 44
Alternative Engine Starting Procedure ........ 45
Normal Engine Starting Procedure.............. 44
Stopping the Engine ........................................ 47
T
Table of Contents .............................................. 3
Turbocharger - Inspect .................................... 98
W
Walk-Around Inspection .................................. 98
Warranty Information..................................... 100
Warranty Section ........................................... 100
Water Pump - Inspect...................................... 99
M0163009 103
Index Section