© 2017 PoolPak LLC. All rights reserved. ComPak
®
Series - Installation, Operation and Maintenance | 3
ComPak
®
Series IOM
SECTION III: PERFORMANCE AND SIZING ................................................................................... 19
ComPak
®
Performance ............................................................................................................................... 19
ComPak
®
AW (AWV, AWH) Performance ....................................................................................................19
ComPak
®
HCD (HCDV, HCDH) Performance ................................................................................................20
ComPak
®
Unit Dimensions .......................................................................................................................... 21
ComPak
®
Horizontal Dimensions ................................................................................................................. 21
ComPak
®
Vertical Dimensions .....................................................................................................................22
ComPak
®
Outside Air Damper Size .............................................................................................................23
Hot Water Coil Capacities .........................................................................................................................24
Factory Refrigerant Charge ........................................................................................................................25
Remote Air-Cooled Condenser (ACC) Performance ........................................................................................26
Electric Duct Heater ................................................................................................................................... 28
General Duct Heater Information ................................................................................................................28
Duct Heater Sizes ......................................................................................................................................28
SECTION IV: INSTALLATION ........................................................................................................ 29
PCP Installation .........................................................................................................................................29
Introduction ..............................................................................................................................................29
Handling .................................................................................................................................................. 30
Clearance ................................................................................................................................................ 31
Mounting of ComPak Units ......................................................................................................................... 31
Inspection .................................................................................................................................................31
Power Supply............................................................................................................................................31
Control Wiring ..........................................................................................................................................31
Condensate Piping .................................................................................................................................... 31
Curb Mounting .........................................................................................................................................32
Integral Gas Furnace Option (RoofComPak Only) .........................................................................................33
CPCS-PCP Controls Field Wiring .................................................................................................................34
Overview .................................................................................................................................................34
Remote Interface Unit (1) ............................................................................................................................34
Cold Surface Temperature Sensor (2) ...........................................................................................................35
Economizer System (Optional) (3) ................................................................................................................35
Outside Air Temperature Sensor (Economizer Option Only) (4) ....................................................................... 36
Air Cooled Condenser (Optional) (5) ........................................................................................................... 36
Auxiliary Pool Water Heating System (AWH Model only*) (6) ........................................................................37
Auxiliary Air Heating System (7) .................................................................................................................37
External Alarm System (8) ..........................................................................................................................37
Building Fire Control System (9) ...................................................................................................................38
Return Air Sensor (10) ................................................................................................................................38
Purge Mode Input (11) ................................................................................................................................38
AC Proof Input (12) .................................................................................................................................... 38
Pool Water Temperature Sensor (13) ............................................................................................................38
Pool Water Piping (AWH and AWV models only*) .......................................................................................40
Salt Water Pools ....................................................................................................................................... 41
Condensate Drains .................................................................................................................................... 41
Water Cooled Condenser ..........................................................................................................................42
Remote Air-Cooled Condenser Installation .................................................................................................... 42
Space and Location Requirements ...............................................................................................................42
Field Installed Piping ..................................................................................................................................44
To Next Page
Loading...
