PoolPak ComPak HCD 3500 - Page 5

© 2017 PoolPak LLC. All rights reserved. ComPak
®
Series - Installation, Operation and Maintenance | 5
ComPak
®
Series IOM
LIST OF TABLES
Table 1-1. Typical Pool Water & Air Temperature Set-Points ..............................................................................9
Table 1-2. Recommended Pool Water Chemistry ...........................................................................................10
Table 2-1. RoofComPak
®
Technical Data .......................................................................................................18
Table 3-1. ComPak
®
AW Performance Summary ........................................................................................... 19
Table 3-2. ComPak
®
HCD Performance Summary ..........................................................................................20
Table 3-3. AW/HCD Horizontal Unit Overall Dimensions ...............................................................................21
Table 3-4. AW/HCD Vertical Unit Overall Dimensions ...................................................................................22
Table 3-5. ComPak
®
Outside Air Damper Size ..............................................................................................23
Table 3-6. Hot Water Coil Capacities ..........................................................................................................24
Table 3-7. Factory Refrigerant R410A Charge ..............................................................................................25
Table 3-8. Remote ACC Performance Chart .................................................................................................. 26
Table 4-1. Horizontal ComPak Curb Dimension .............................................................................................33
Table 4-2. R410A Charge for Air Cooled Condensers (lb.) .............................................................................46
Table 4-3. Refrigerant (R410A) Charge for Different Line Size .........................................................................47
Table 5-1. Solenoid Activation ....................................................................................................................65
Table 5-2. Pool Water Chemistry .................................................................................................................70
LIST OF FIGURE
Figure 2-1. ComPak
®
AW and HCD Typical Refrigerant System Schematic .......................................................13
Figure 2-2. PCP RoofComPak
®
Dimensions ....................................................................................................18
Figure 3-1 AW/HCD Horizontal Unit Elevation and End Views........................................................................21
Figure 3-2. AW/HCD Vertical Unit Elevation and Plan Views ..........................................................................22
Figure 3-3. Air-Cooled Condenser (PoolPak
®
) - Isometric Views .......................................................................27
Figure 3-4. Air-Cooled Condenser (Bohn) - Elevation Views ............................................................................27
Figure 3-5. Duct Heater ..............................................................................................................................28
Figure 4-1. Typical ComPak
®
AWH Series System Layout................................................................................29
Figure 4-2. RP Lift Views .............................................................................................................................30
Figure 4-3. RoofComPak
®
Curb Assembly ....................................................................................................32
Figure 4-4. ComPak Horizontal Curb Assembly ............................................................................................33
Figure 4-5. Remote Interface Mounting Plate .................................................................................................34
Figure 4-6. Economizer Operation ..............................................................................................................35
Figure 4-7. Outside Air Sensor ....................................................................................................................36
Figure 4-8. PAC Unit Field Wiring ...............................................................................................................36
Figure 4-9. Installation of a Hot Water Coil 3-Way Valve ...............................................................................37
Figure 4-10. Field Wiring Schematic ............................................................................................................ 39
Figure 4-11. Typical Pool Water Piping Diagram (AWH and AWV Model Only)* .............................................. 41
Figure 4-12. AWH and HCDH Condensate Trap ...........................................................................................42
Figure 4-13. Remote ACC Installation Around Walls or Obstructions ............................................................... 43
Figure 4-14. Remote ACC Installation When Installing Multiple Units ...............................................................43
Figure 4-15. Remote ACC Installation When Installing Units in Pits ................................................................... 43
Figure 4-16. Remote ACC Installation When Installing Units Near Decorative Fences ......................................... 44
Figure 4-17. ACC Refrigerant Piping .............................................................................................................45
Figure 5-1. RIU Keypad ..............................................................................................................................48
Figure 5-2. Initial Startup Screen .................................................................................................................48
Figure 5-3. Status Screen 1 ........................................................................................................................48
Figure 5-4 Status Screen 4 .........................................................................................................................49