Rowe BC-3500 - Parts Catalog

To Next Page

To Previous Page

Rowe by American Changer

1400 N.W. 65th P

lace

Fort Lauderdale, Florida 33309

techsupport@rowebillchangers.com

Printed in USA

BC-3500

Bill and Coin Changer

Field Service Manual

and

Parts Catalog

Main Page

Parts Catalog2
Machine Safety3
Important Safety Instructions4
Setup & Installation5
Mounting Instructions5
Preface8
Table of Contents9
BC-3500 Major Components13
Section 1: System Description14
- Changing Coins15
Introduction14
General Operation14
- Changing a Bill14
Functional Description15
- Bill Transport15
- Bill Transport (Top View)15
- Dual Bill Stacker16
- Bill Transport (Bottom View)16
- Coin Acceptor17
- Coin Acceptor Options17
- Solid-State Coin Switches18
- Coin Dispenser18
- Coin Dispenser (Rear View)18
- Coin or Bill Return Button19
- Hoppers19
- Bill Return Switch19
- Hopper Capacities20
- Machine Capacities (Bill Stacker, Coin Box)20
- Temporarily out of Service Lamp21
- Power Control Center21
- Computer Control Center22
Denominations Accepted24
Installation & Programming26
Section 2 - Installation and Programming26
Wall Mounting26
- Installing a 1/2-Inch Conduit27
- Attaching the BC-3500 to a Wall27
- Mounting Detail - Wood Frame Wall27
- Mounting Detail - Masonry Wall27
- Maximum Escrow Bucket Capabilities28
Change Payout Programming28
Acceptance Combinations Which Are Not Allowed29
Loading the Hoppers30
Unloading the Hoppers30
Operational Information31
Setting up the Bc-350032
- Quick Setup for a BC-3500 Dispensing Quarters Only32
- Normal Setup33
- Key Information33
- Turning the Power on33
- Switching to the Programming Mode34
SECTION 2 - INSTALLATION & PROGRAMMING (Continued)40
Transport Self-Clear Check40
Self-Diagnostics40
- Diagnostic Check40
- Fault Message Check40
  - Bill Acceptance Messages40
- Status Messages40
  - Non-Shutdown Faults40
Acceptance Check41
Dispensing Tokens42
- Token Control43
Fast-Feed Shutdown43
- Accessing the FAST-FEED Menu44
- Navigating the FAST-FEED Menu44
- XYZ Table44
Anti-Pullback System45
- Accessing the ANTI-PULLBACK Menu46
- Navigating the ANTI-PULLBACK Menu46
Miscellaneous46
Section 3: Routine Service48
Introduction48
Removing a Jammed Bill from the Bill Acceptor48
Bill Jamming Check List48
Transport Check Points49
Filling and Emptying the Bc-350049
Filling the Changer49
- Removing the Coin Inlet Screw50
- Cleaning the Coin Inlet50
Emptying the Changer50
Coin Inlet Cleaning Procedure50
Cleaning the Hopper Coin Path51
Change Bucket Lubrication53
Test Procedures53
- Checking a Bucket Solenoid53
- Transport Motor Speed Check53
- Testing BC-3500 Transport Photocells54
- Coin Counting Phototransistor (Detector) Check55
- A. Sensor Check55
Adjustments56
- Bill and Coin Return Switch Assembly56
  - Coin Inlet to Top Door Clearance56
  - Bill Return Switch Adjustment57
- Hopper Chain Adjustment57
  - Adjusting the Bill Acceptor Rails59
  - A. Bill Acceptor Rail Adjustment59
- Adjusting the Bill Transport to Stacker Alignment60
- Bill Stacker60
  - Home Switch Adjustment60
- Adjusting the Upper Bill Box62
- Upper Bill Box Adjustment62
- Bill Stop Flipper Check63
- Adjusting the Bill Stop Flipper64
- Installing a New or Replacement Bill Stacker64
- Timing Belt Tension67
- Timing Belt Tension Adjustment67
Section 4: Troubleshooting68
Introduction68
- Sequence Descriptions69
Power up Diagnostics68
Machine Status69
- Standby Mode69
- Accept, Payout, and Replenish Modes70
- Reject Mode70
- Out of Service Mode70
Index to Error Messages and Troubleshooting Charts71
Validation Rejects73
- Cell Sequence Rejects73
Reject - Bill (A)83
Bill Parameter Rejects83
- Reject - Bill (D)84
- Reject - Bill (E)84
- Reject - Accpt off86
- Reject - Fast Feed86
- Reject - no Denom86
- Reject - Return Sw86
- Transport Errors87
- Ck Transport Mag87
- Ck Transport VI87
Clearing Errors87
- Ck Transport Vf88
- Ck Transport Vr88
- Ck Transport Vt88
- Changer Errors (Non-Shutdown)89
- Ck Left Test Sw89
- Clearing Machine Errors89
- Machine Errors89
- Ck L Coin Detctr96
- Coin Detector Errors While in the Standby Mode96
Bill Changer Errors (Shutdown)96
MC Dispense Mode114
- Ck Stacker115
- Ck Stacker Nl115
- Bucket Pwr Flt117
- Bucket Not Open119
- Bucket Stays on121
- Bill Changer Steals Coins - Works OK with Bills125
- Bill Changer Steals Bills - Works OK with Coins126
- Bill Changer Gives Erratic Payout for Bills and Coins128
- Bill Stacker Problems129
- +5 VDC Failure, +5 VDC LED out130
Detailed Control Computer Board Operation131
- Control Computer131
- Output Circuits133
- Input Circuits134
- Power Supply Circuit Board143
- Bill Stacker Driver Circuit Board170
- Coin Switch Circuit Board172
Section 5: Additional Information176
Harness Color Coding176
- Functions177
- Grounds177
- Supply Voltages177
- Introduction182
- Ordering Replacement Parts182
- Parts List Description182
- Bill and Changer Assembly183
- Top Cabinet Assembly185
- Top Cabinet Door Assembly185
  - Standard Top Door186
  - “New Style” Top Door186
  - Top Cabinet Assembly187
  - Front Door Assembly191
- Base Cabinet Assembly193
- BA-50 Bill Acceptor Assembly195
- Power Control Center Assembly199
- Control Computer Assembly201
- Control Computer Assembly202
- Coin Dispenser Assembly203
- Change Bucket Assembly205
- Hi-Capacity Hopper Assembly207
- Coin Acceptor Bracket and Harness Assembly209
- B. Coin Acceptor Bracket and Harness Assembly211
- Dual Bill Stacker Assembly213
- Coin Inlet and Chute Assembly with Reject Button217
- Accessory Kits219
- Repair Kits and Spare Parts219

Rowe BC-3500 - Parts Catalog

Table of Contents

Related product manuals