REPAIR
0607SE Maintenance Manual 6-13 © Jan 2022
ELECTRICAL SYSTEM
Use and Maintenance of Battery
The battery falls into 3 types: lead acid, lead acid
maintenance-free and lithium batteries. The lithium
battery and lead acid maintenance-free battery are free
of maintenance.
FIRE AND EXPLOSION HAZARD
• Batteries contain sulfuric acid and
generate explosive mixtures of
hydrogen and oxygen gases.
Keep any device that may
produce sparks or flames (-
including cigarettes/smoking
materials) away from the battery
to prevent explosion.
• Do not touch the battery terminals
or cable clips with tools that may
produce sparks.
ELECTROCUTION HAZARD
• Contact with hot circuits may
cause serious injury or death. Be
sure to wear goggles, gloves and
protective clothing.
• Remove all rings, watches and
other accessories.
CHEMICAL BURN HAZARD
• Avoid spilling battery acid on
unprotected skin or unprotected
skin in contact with battery acid.
Seek medical attention
immediately if the skin comes in
contact with battery acid .
• If the battery acid escapes, please
use baking soda to neutralize the
acid.
UNSAFE OPERATION HAZARD
• Strictly follow the manufacturer’s
recommendations on how to
properly use and maintain the
battery.
• Cut off the battery main switch if
the battery is not to be used for
an extended period.
• The waste battery may pose
danger, so do not discard
batteries at will. If it needs to be
scrapped, contact a battery
recycling company.
• Except for the professionals, do
not perform a systematic
maintenance or service to the
battery, otherwise it may cause
bodily injuries or damage to the
battery system.
• Except for the professionals, do
not tamper with the settings or
service a signal light, otherwise it
may cause bodily injuries or
damage to the battery system.
• Except for the professionals, do
not remove the battery housing,
otherwise it may cause damage to
the battery system.
NOTICE
It will not be covered by the warranty if the battery
attenuates or fails due to customer’s overuse (-
continued use after battery level less than 10%) or
battery out of charge for a long time (not timely
charged for 3 days or longer when the battery level
less than 10%).
Inspection
See the Inspect the Battery section in this manual.
Cleaning
1. Clean the top, terminals and connections of the
battery with a cloth or brush and mixed solution of
sodium bicarbonate and water. Do not let the
cleaning solution enter the battery.
2. Clean the top, terminals and connections with water
and wipe them dry with a cloth. Apply a thin layer of
petroleum jelly to the terminals or use terminal
protector.
3. Keep the area around the battery clean and dry.
Charging
To Next Page
Loading...
