Sodi Sigma DD2 - 6.2 - Tyres

This document can not be reproduced or released without the Sodikart authorization.
MAN.SIG.EN.02
04/2014
38
CONFIGURE THE KART ACCORDING TO THE GUIDE INSTRUCTIONS
User maintenance guide
6.2 - Tyres
6.2.1 - Tyres change
0
1
2
3
4
5
6
7
8
9
3
6
4
5
2
1
Legend
1 Rim
2 Tyre
3 Direction of rotation
4 Ination system
5 Grease
6 Tyre iron
● Place the kart on a trolley.
● Place the wheel on a tyre remover (OU942.002).
● When the tyre (2) is detached on both sides, remove
it completely using tyre irons (6).
● Take the new tyre and grease the tyre (grease
LU823.003 (5)) in order to make assembly and
removal easier.
● Replace the tyre (2) on the valve side of the wheel
rim (1) ensuring the correct rotation direction.
● Once in place, strap your tyre with a belt when you
inate more than 3 bars.
● Put the wheel back on the kart and tighten the nuts
back again securely.
● Adjust the pressure with a manometer (4)
(OU943.002).
●● Always●change●the●whole●set●whenever●a●
tyre●is●changed●(fronts,●rears,●or●all●the●set).
●● Always●place●the●tyres●so●that●they●rotate●in●
the●direction●indicated●on●the●tyre●wall.
●● Never●inate●the●tyres●more●than●4●bars.
●● Excessive●wear●of●tyres●can●be●result●from●
bad●front●wheel●axle●unit●alignment.
●● Use●tyres●with●a●grip●adapted●to●your●track.
●● Give●worn●tyres●at●a●specialist●of●tyre●
treatment●according●to●local●environmental●
regulation.
► Change all damaged rims. A damaged
rim may lead to a loss of tyre or loss of
pressure and may lead to a serious or
even fatal injury.
► Check the tyre wear daily. Worn or
damaged tyres may lead to a serious or
even fatal injury.
► Never run with worn or damaged tyres:
a burst of tyre may lead to a serious or
even fatal injury.
► Always blow up tyre with the pressure
recommended by the manufacturer.
► Cold tyres have a reduced adherence,
and increase the loss of control of the
kart. This may lead to a serious or even
fatal injury.
► Too much grip reduces the stability of
the kart under impact, and lead to a
tendency to go on two wheels. It also
increases the risk of riding over.
► Store tyres in an appropriate area to
prevent re hazard.
► Never inate above 4 bars: there is a
risk of severe injury due to potential
failure of the rim.