2-12 PERIODIC MAINTENANCE
CARBURETOR SYNCHRONIZATION
(!4-25)
PAIR (AIR SUPPLY) SYSTEM
(!3-97)
FUEL FILTER
• Lift up the fuel tank. (!2-10)
Check the fuel filter
1 for evidence of dirt and contamination. If
present, replace the fuel filter with a new one. (!4-6)
CLUTCH CABLE PLAY
• Loosen the locknut
1 and turn the adjuster
2 all the way into
the clutch lever assembly.
• Remove the clutch release cover.
• Loosen the locknut
3, and turn out the adjusting screw
4 two
or three rotations.
• Then, slowly turn in the adjusting screw
4 until resistance is
felt.
• Then, turn out the adjusting screw
4 1/4 of a turn, and tighten
the locknut
3.
• Loosen the locknut
5, and turn the cable adjuster
6 to obtain
10 – 15 mm of free play
A at the clutch lever end.
• Tighten the locknut
5.
" Clutch cable play
A: 10 – 15 mm
Inspect initially at 1 000 km (2 month) and every 12 000
km (24 months).
Inspect every 12 000 km (24 months).
Inspect every 6 000 km (12 months) and replace every
12 000 km (24 months).
Inspect every 6 000 km (12 months).
To Next Page
Loading...
