Vanair 050817 - Section 3: Specifications

AIR N ARC
®
200 SERIES ALL-IN-ONE POWER SYSTEM
®
SECTION 3: SPECIFICATIONS
090019-OP_r0 PAGE - 31
SECTION 3:
SPECIFICATIONS
TABLE 3A: WELDER, GENERATOR, AND ENGINE SPECIFICATIONS
SYSTEM INFORMATION
SPECIFICATION
Rated Welder Output 200A High Frequency DC/CC, DC/CV; 100% Duty Cycle @ 200 Amps
Welding Leads 25 or 50 Ft. Optional (Refer to Section A.5 for Optional Parts Listing)
AC Generator 5,000 Watts Continuous Duty
AC Generator 120V Power Rating 60 Hz 1 PH, 2-20 Amp Circuits
AC Generator 240V Power Rating 60 Hz 1 PH, 20 Amp
Battery Charger Capacity 12V Charge, 12V Boost, 24V Boost
Engine
25 EFI
I
Engine Oil Capacity
Two (2) Quarts 10W30 (Refer to Engine Operator’s Manual for Extreme Conditions)
Fuel Consumption 1.27 GPH at Full Engine Speed/Load (Approx. 8.6 Hour Runtime w/ 11Gal. Tank)
Fuel Tank Capacity 11 Gallons (41.6 L)
Fuel Type
87 Octane or Higher Unleaded Gasoline
II
Operating Temperature Limits
-20°F to 110°F (-29° to 43°C): Consult Section 5.8, Extreme Condition
Operation
I
For in-depth specifications and requirements regarding the Kohler
®
25 EFI engine, refer to the Engine Operator’s
Manual.
II
Ethanol blended fuels, such as E85, are prohibited for use with the Kohler 25 EFI engine. DO NOT use ethanol-
based fuels.
TABLE 3B: AIR COMPRESSOR SPECIFICATIONS
COMPRESSOR INFORMATION SPECIFICATION
Compressor Type Reciprocating, Dual-Stage
Air Compressor Capacity 24 CFM @ 175 PSI
Air Filter Pleated Paper, Dry Type
Oil Capacity/Type
Service: 1.75 Quarts
ISO68 Premium Non-Detergent Lubricant
Air Tank Capacity Thirty (30) Gallons or Remote Tank
Tank Pressure Rating 200 PSI
Safety Relief Valve Setting 200 PSI
Operating Range (ambient)
-20°F to 110°F (-29° to 43°C): Consult Section 5.8, Extreme Condition
Operation
Electrical System 12 VDC
Cooling System Air to Oil Heat Exchanger
Instrument Gauges Pressure and Hour Meter
Adjustable Air Pressure Control
Settings
Factory Preset Pressure: 150 PSI (Cut-In) / 175 PSI (Maximum Cut-Out)
Air Service Outlets Two (2) on Control Panel (remote panel version), One (1) on Machine