FULTON FHE-250 - Safety Information; Emergency Procedures; Safety Regulations Overview

FHE-250 MANUAL 09 2014 ISSUE 2
The Pressure System Safety Regulations 2000
Fulton Boilers fall within the scope of the Pressure Systems Examination Scheme.
Regular inspections are therefore required by a ‘Competent Person’.
The scope of the examination and the actual intervals between examinations is at the discretion of the
competent person.
It is the responsibility of the user to provide a written scheme of examination for those parts of the
system in which a defect may give rise to danger.
Instructions in this manual are provided for the safe operation and maintenance of the boiler and do
not cover periodic statutory inspections.
For further information contact:-
(a) SAFed
SAFETY ASSESSMENT FEDERATION Limited.
Nutmeg House,
60 Gainsford Street,
Butlers Wharf,
London, SE1 2NY.
(b) Health and Safety Executive local ofce.
(c) Your Competent Person.
For your Safety!
The following WARNINGS, CAUTIONS and NOTES appear in various sections of this manual.
WARNINGS must be observed to prevent
serious injury or death to personnel.
CAUTIONS must be observed to prevent
damage or destruction of equipment or loss of
operating effectiveness.
NOTES: must be observed for essential and
effective operating procedures, conditions and
as a statement to be highlighted.
It is the responsibility and duty of all personnel
involved in the operation and maintenance of this
equipment to fully understand the WARNINGS,
CAUTIONS and NOTES by which hazards are to be
eliminated or reduced.
Personnel must become familiar with all aspects of
safety and equipment prior to operation or
maintenance of the equipment.
WARNING
Hot Water Boilers are a potential hazard, possibly fatal if not properly
maintained.
CAUTION
It is vitally important that the instructions
given in this manual are strictly adhered to.
Failure to carry out the routine maintenance
checks could result in a drastic reduction in the
life expectancy of the boiler.
CAUTION
Incase of Emergency
This boiler has been designed and constructed to meet all of the essential requirements of the applicable
European Directives and subject to proper maintenance should not give occasion to any hazardous conditions.
If such a condition should occur during commissioning or during subsequent operation of this product, what so
ever the cause, then the fuel supply to the boiler should be isolated immediately, until such time that the fault
has been investigated by a competent person and rectied.
!
!
!
!
!