LUBRICATION & PERIODIC MAINTENANCE
79
STORAGE
FIG. 6-50: If Tractor is to be stored for extended periods,
such as off-season nonuse, certain measures should be
taken for its preservation during such periods. These
measures will vary according to geographicat area and
storage season.
1. Replace engine oil and filter. Operate at low idle five
minutes to lubricate parts.
2. Lubricate all grease fittings and lightly oil control link
age pivots.
3. Detach implements.
4. Store Tractor in enclosed area, if possible, for protec-
tion from weather.
5. Block up Tractor to remove weight from tires and to
protect tires from oily or damp floor.
6. Raise and lock three-point lift linkage in up position by
turning lowering rate control knob, 1, fully clockwise.
FIG. 6-51: Step 7 - Fill fuel tank to prevent condensation
from forming on inside of tank. Turn filter valve, 2, to OFF
position.
8. Remove battery and store in cool dry place. Maintain
charge during storage period.
9. If Tractor is stored during cold weather season insure
that antifreeze is adequate. Alternatively, radiator and
engine block may be drained.
10.Check with your diesel fuel supplier on the availability
of a diesel fuel additive to place in the fuel system dur-
ing storage period.
11.If Tractor cannot be placed in an enclosed area place
it under some sort of cover and cover exhaust pipe to
prevent entrance of rain or snow.
12.Touch up scratches with paint.
At the end of storage period:
Perform appropriate lubrication and maintenance before
placing Tractor back in service. See “Lubrication and
Maintenance” section.
Conduct full pre-start inspection. Make sure all con-
trols operate correctly.
Allow engine to idle approximately 30 minutes.
Check for leaks and repair as required.
FIG. 6-50
FIG. 6-51
To Next Page
Loading...
