Complete Parts List is available at www.MillerWelds.com
OM-262506 Page 55
Trouble Remedy
Engine hard to start in cold weather
(continued).
Have Factory Authorized Service Agent check Preheat switch S4, control relay CR3, and the glow
plug.
Engine suddenly stops. Check oil and coolant levels. Automatic shutdown system stops engine if oil pressure is too low or coolant
temperature is too high (see Sections 5-6 and 5-7).
Check fuel/hour meter for indication of shutdown.
Reset supplementary protector CB2 and/or clear fault causing circuit breaker CB1 to trip (see Section
8-10). Have Factory Authorized Service Agent check engine alternator, engine harness, fuel solenoid
FS1, and the fuel pump.
Have Factory Authorized Service Agent check Engine Control switch S1, control relay CR1, inte-
grated rectifier SR2, fuel solenoid FS1, and the fuel pump.
See engine manual.
Engine slowly stopped and cannot be
restarted.
Check fuel level.
Check fuel/hour meter for indication of shutdown.
Check engine air and fuel filters (see Sections 8-7 and 8-11).
See engine manual.
Battery discharges between uses. Turn Engine Control switch off when unit is not running.
Clean top of battery with baking soda and water solution; rinse with clear water.
Recharge or replace battery if necessary. It may be necessary to remove oil filter to replace battery.
Periodically recharge battery (approximately every 3 months).
Engine idles, but does not come up to
weld speed.
Have engine Factory Authorized Service Agent check engine speed control system.
Engine does not run at idle speed. Have engine Factory Authorized Service Agent check engine speed control system.
Engine uses oil during run-in period;
wetstacking occurs.
Dry engine according to run-in procedure (see Section 11).
SECTION 9 − PARTS LIST
9-1. Recommended Spare Parts
Description
Part
No.
Dia.
Mkgs. Quantity
F1 085874 Fuse, Mintr Cer Slo−blo 10. Amp 250 Volt 1........... ..... .. ..........................
244290 Brushholder Assembly, Generator w/Leads 1.................... .. .........................
242883 Belt, Alternator (Mitsubishi) 1.................... .. .......................................
252782 Filter Kit, Mitsubishi (S4l2) (Includes) 1.................... .. ...............................
252781 Filter, Fuel Spin−on 1.................... .. ............................................
213858 Filter, Fuel In−line 5/16x5/16 Mic 125 −175 1.................... .. .......................
242882 Filter, Lube Oil 1.................... .. ................................................
197676 Element, Air Cleaner 1.................... .. ..........................................
♦197679 Element, Air Cleaner Safety 1.................. .. ......................................
Battery, Stor 12v 500 Crk 75 Rsv Gp 55 1.............................. ...........................
♦Optional
To maintain the factory original performance of your equipment, use only Manufacturer’s Suggested
Replacement Parts. Model and serial number required when ordering parts from your local distributor.
To Next Page