Primus DAM 9 User Manual

128 pages

To Next Page

To Next Page

Page #1 background image

Loading...

Page #1 background image

DAM 9

SERVICE MANUAL INDUSTRIAL DRYERS

PUBLICATION DATE: 02/01

516514

Table of Contents

Default Chapter3
- Table of Contents3
Section 1 - Safety Information5
- Locating an Authorized Servicer6
Section 2 - Introduction7
- Customer Service7
- Nameplate Location7
- Model Identification8
- How Your Dryer Works10
Section 3 - Troubleshooting11
- 1 Motor Does Not Run11
- 2 Unit Stops in Cycle; Quits after the First few Loads; Has a Burning Smell; Cycles on Motor Thermal Protector12
- 3 Motor Runs but Cylinder Does Not Turn13
- 4 Motor Does Not Stop13
- 5 Heating Assembly Does Not Heat or Burner Does Not Ignite14
- 6 Igniter Does Not Glow (Gas Supply Sufficient) - Gas Models15
- 7 Burner Ignites and Goes out Repeatedly - Gas Models15
- 8 Igniter Glows but Burner Does Not Ignite - Gas Models15
- 9 Heater Assembly or Burner Shuts off Prematurely16
- 10 Heater Assembly or Burner Repeatedly Cycles off on Limit Thermostat16
- 11 Heater Assembly or Burner Does Not Shut off17
- 12 Clothes Do Not Dry17
- 13 Clothes Are too Hot When Removed from Dryer18
- 14 Ignition Control Flashes19
Section 4 - Grounding21
- 15 Ground Wires from Terminal Block or Power Cord to Rear Bulkhead and from Rear Bulkhead to Control Housing21
- 16 Metered and Nonmetered Models - Ground Wires from Rear Bulkhead to Accumulator Bracket or Timer (Depending on Model) and from Cabinet Top to Control Panel22
- 17 Ground Wires from Rear Bulkhead to Timer Mounting Bracket and to Dryer Cabinet Top23
  - Ground Wires from Timer Mounting Bracket to Graphic Panel23
18 Ground Wires from Dryer Base to Wire Harness and to Ignition Control (Gas Models with Silicon Nitride Ignition System)23
Section 5 - Service Procedures25
19 Access Panel25
20 Control Panel and Controls (Metered and Nonmetered)25
- To Test Push-To-Start Switch25
21 Graphic Overlay27
- To Test Fabric Selector Switch27
22 Timer (Nonmetered Models)28
- To Test Timer Contacts (Nonmetered Models)28
23 Accumulator (Metered Models)30
- To Test Accumulator (Metered Models)31
24 Electronic Control32
25 Coin Drop34
26 Meter Case (Metered Models)39
27 Timer Case (Nonmetered Models)41
28 Security Case and Card Reader42
29 Control Hood45
30 Cabinet Top (Nonmetered Models)45
31 Cabinet Top (Metered Models)46
32 Lint Filter47
33 Loading Door and Door Hinge47
- Reversing Door Procedure48
34 Inner and Outer Door Panels and Door Pull49
35 Door Strike49
36 Door Seal50
37 Front Panel and Panel Seal51
38 Door Switch51
- To Test Door Switch51
39 Door Catch51
40 Door Hinges53
41 Hold-Down Clips and Locators53
42 Burner System Components (Gas Models)54
- To Test Gas Valve Coils (Gas Models)56
- To Test Igniter (Gas Models)57
- Ignition Control Grounding Check57
- To Test Electrical Circuit to Ignition System (Gas Models)57
- To Test Sensor (Gas Models)57
- 43 Burner Housing and Heat Shroud (Gas Models)59
- 44 Limit Thermostat59
  - To Test Heater Assembly (Electric Models)59
- 45 Heating Element (Electric Models)60
- 46 Thermistor or Thermostat61
  - To Test Thermal Fuse (Electric Models)61
  - To Test Cycling or Limit Thermostat62
- 47 Air Duct62
- 48 Motor and Exhaust Assembly62
  - To Test Drive Motor66
- 49 Front Bulkhead Assembly69
- 50 Cylinder Belt71
- 51 Cylinder Assembly72
- 52 Rear Seal73
- 53 Cylinder Rollers75
- 54 Outlet Cover75
- 55 Rear Bulkhead and Heater Box76
- 56 Terminal Block or Power Cord78
Section 6 - Adjustments87
- 58 Leveling Legs87
- 59 Burner Flame (Gas Models)88
Section 7 - Internal Wiring of Dryer Motor Switch91
Section 8 - Wiring Diagrams93
- Model SDE707*F150094
- Model SDE607*F150095
- Models SDE407*F1500 and SDE507*F150096
- Models SDE107*F1500, SDE107*F1724 and SDE307*F150097
- Model SDG409*F305898
- Model SDE009*F305899
- Model SDE407*F4350100
- Model SDE407*A3000101
- Model SDE107*F4350102
- Model SDE007*F4350103
- Model HDG709*F1102104
- Model HDG509*F1102105
- Models HDG109*F3000, SDG109*F3000 and SDG109*F5412106
- Models HDG109*F1102 and SDG109*F1124107
- Models HDG009*F3000, SDG009*F3000 and UDG009*F3000108
- Models HDG109*G3013 and SGG109*G3013109
- Model HDG009*F1102110
- Model HDG009*G3008111
- Models HDE707*F1502 and HDE707*F1702112
- Models HDE507*F1502 and HDE507*F1702113
- Models HDE107*F3000, SDE107*F3000 and SDE107*F5412114
- Models HDE107*F1502 and HDE107*F1702115
- Models HDE107*G3003, HDE107*G3018 and SDE107*G3018116
- Model HDE007*F1702117
- Models HDE007*F3000, SDE007*F3000 and UDE007*F3000118
- Models HDE007*G3003, HDE007*G3008, HDE007*G3010 and SDE007*G3018119
- Model UDE007*F3025120
- Model UDG009*F3025121
- Models HDEB07*J1502, HDEB07*J1702, HDEF07*J1502, HDEF07*J1702, SDEA07*J1500, SDEB07*J1500 and SDEF07*J1500122
- Models HDGB09*J1102 and HDGF09*J1102123
- Model SDEA07*J3000124
- Model SDEA07*J4350125

Questions and Answers:

Need help?

Do you have a question about the Primus DAM 9 and is the answer not in the manual?

Primus DAM 9 Specifications

General

Brand	Primus
Model	DAM 9
Category	Dryer
Language	English

Related product manuals

Preview: Primus D55