Scheppach SG5200D User Manual

www.scheppach.com
24
|
GB
Check the oil level (g. 6 + 8)
Remove the maintenance cover (5). Remove the oil
ller cap (22) and wipe the dipstick clean. Check the
oil level by inserting the dipstick into the lling nozzle
without screwing the cap on. If the oil level is too low,
rell with the recommended oil up to the lower rim of
the oil lling nozzle.
Fill with fuel
• In order to refuel the device, open the tank cover (3)
by turning it anti-clockwise.
• Fill storage tank with fuel
• Close the tank by turning the tank cover (3) clock-
wise.
Recommended fuel
This engine only requires diesel.
m Only use fresh, clean fuel.
Water or impurities in the diesel damage the fuel sys-
tem.
Tank volume: 16 litres
m Refuel in a well-ventilated area with the engine
stopped. If the engine was in operation immedi-
ately before, allow it to cool rst. Never refuel the
engine in a building where the diesel vapour may
come into contact with ames or sparks.
Diesel vapour is highly ammable and explosive.
When handling fuels, you may su󰀨er burns or oth-
er severe injuries.
• Switch o󰀨 the engine and keep it away from heat,
sparks and ames.
• Only refuel outdoors.
• Mop up spilled diesel immediately.
Electrical safety
Electrical supply lines and connected devices must be
in perfect condition.
Only devices whose voltage information matches with
the output voltage of the power generator may be con-
nected.
Never connect the power generator to the mains (socket).
The power lines to the consumer must be kept as short
as possible.
Environmental protection
Take any contaminated maintenance material and op-
erating materials to a collection point designated for
this purpose. Recycle packaging material, metal and
plastic.
If possible, keep the packaging until the expiry of the
warranty period.
Familiarise yourself with the product by means of the
operating instructions before using for the rst time.
With accessories as well as wearing parts and replace-
ment parts use only original parts. Replacement parts
can be obtained from your dealer.
When ordering please provide our article number as
well as type and year of manufacture for your equip-
ment.
m ATTENTION!
The device and the packaging material are not
children’s toys! Do not let children play with plas-
tic bags, lms or small parts! There is a danger of
choking or su󰀨ocating!
8. Assembly / Before commissioning
The device is preassembled at the factory!
Before commissioning
Connect the battery (g. 5)
Prepare battery and connect.
Fit the battery (21) in the device using the battery at-
tachment set (19). Now connect the red cable (+) and
then the black cable (-) to the battery.
m ATTENTION!
Check before starting the engine:
• Check the fuel level, rell if necessary - the tank
should be at least half-full
• Ensure the device has su󰀩cient ventilation
• Disconnect any connected electrical devices from
the power generator
• The condition of the air lter,
• The condition of the fuel lines,
• The rm seating of the external screw connections,
Attention! Fill the oil before rst use.
Before each use, check the oil level with the engine
switched o󰀨 and on a level surface. Use the highest
quality four-stroke oil or an HD oil with the same level
of quality. SAE 15W-40 is recommended for general
use at all temperatures.

Scheppach SG5200D Specifications

General

Fuel type	Diesel
Rated power	3000 W
Engine power	7.7 hp
Maximum power	5000 W
Rated voltage	230 V
Ignition system	Electronic
Rated frequency	50 Hz
Fuel consumption	1.43 l/h
Fuel tank capacity	16 L
Engine displacement	418 cm³
Engine number of strokes	3
Castor wheels	Yes
Product color	Black, Blue
Inverter technology	-

Weight and Dimensions

Depth	920 mm
Width	520 mm
Height	750 mm
Weight	148000 g
Package depth	710 mm
Package width	935 mm
Package height	535 mm
Package weight	160000 g