MN-35949 • Rev 04 • 06/16 • Combitherm® CT PROformance™ Series • Technical Service Manual • 41
Cleaning and Maintenance
In addition to the routine cleaning and maintenance
procedures, there are several additional steps to be
taken for both sanitation and to keep the oven running
ef ciently. Refer to the following inspection checklists
for a comprehensive approach to longevity and
equipment ef ciency. These additional safeguards will
help prevent down time and costly repairs.
DO NOT DISPOSE OF GREASE, FAT, WOOD CHIPS OR
SOLID WASTE DOWN THE OVEN DRAIN.
Fats and solids will eventually coagulate in the drain
system, causing blockage. Consequently, water
will back-up into the condenser and interior oven
compartment, resulting in an oven that is inoperable.
MAKE CERTAIN THE DRAIN SCREEN IS ALWAYS IN
PLACE. REMOVE ANY SOLID WASTE MATERIAL FROM
THE oven bottom and DRAIN SCREEN BEFORE IT
ENTERS THE DRAIN SYSTEM.
The routine removal of solids from the drain screen will
help prevent blockage.
USE THE AUTHORIZED COMBITHERM OVEN
CLEANER ONLY.
The use of unauthorized cleaning agents may discolor or
harm the interior surfaces of the oven.
TO PROLONG THE LIFE OF THE DOOR GASKET, CLEAN
THIS ITEM DAILY.
The acids and related compounds found in fat,
particularly chicken fat, will weaken the composition of
the gasket unless cleaned on a daily basis. Wipe with a
hot, soapy cloth.
TO ADDITIONALLY PROTECT GASKET LIFE, ALLOW
OVEN DOOR TO REMAIN SLIGHTLY OPEN AT THE END
OF THE PRODUCTION DAY.
An open door will relieve the pressure on the door gasket.
ROUTINELY CLEAN DOOR HINGES.
Open oven door to relieve tension. Clean all parts of
thehinge.
ON A MONTHLY BASIS,
DECALCIFY OR DESCALE
THEOVEN.
Using the Scale Free cleaner,
CE-27889, place 7 ounces of
the product in the drain. Run
a Heavy-Duty cleaning cycle.
A er the cleaning cycle has been
completed, use the hand shower
to spray down the oven interior.
Swing open the interior fan guard
and spray down the area behind
the panel. Direct a stream of
water down the interior drain
cover to thoroughly rinse the cleaner out of the oven.
A er the oven interior has been sprayed down, run a
RINSE cleaning cycle.
WARNING
When smoking is completed, remove smoker box
from oven. Dispose of wood chips in a fire proof
waste receptacle to prevent the risk of fire.
To prevent serious personal injury, death, or
property damage:
Do not steam clean, hose down or flood the
interior or exterior with water or liquid solution
of any kind. Do not
use water jet toclean. Failure
to observe this precaution will void the warranty.
Preventative Maintenance
To Next Page
Loading...
Need help?
General
