Installation
15
Initial Startup
The following is a check-list to be completed by
qualified personnel prior to turning on the
applianceforthefirsttime.
j Open the manual shut -off valve at the rear of
the oven.
j Remove the control panel and combustion
covers.
j Turn the combination valve’s manual shut-off
to the on position.
j Turntheselectorsw itchto Cook,and thet her-
mostat t o 500_F (260_C).
The ovenmain burner lights, and the OvenReady
Light comes on. With the main burner on, check
the following.
j Verify there are no gas leaks, by checking all
gas connections with a soapy water solution.
j Verify that the inletpressure iscorrect. The in -
let pressure can be checked at the pressure
tap located on the combination valve’s inlet
side.
j Verify that the manifold pressure is correct.
The manifold pressure can be checked at the
pressure tap located on the combination
valve’s outlet side.
j If the above pressure readings are set to the
recommended pressure requirements, allow
the oven toburn-offfor2 hours. If thepressure
readingsarenotsetcorrectly,turnofftheoven
and readj ust accordingly.
WARNING
The break in procedure burns off e xcess
oils present in the metals during fabrica-
tio n. Smoke may b e produced. Proper
ventilation is required.
ADJUSTMENTS ASSOCIATED WITH INITIAL
INSTALLATION
Each oven, and its component parts, have been
thoroughly tested and inspected prior to ship-
ment. However,it is oftennecessary to further test
or adjust the oven as part of a normal and proper
installation. These adjustments are the responsi-
bility of the installer, or dealer. Since these adjust-
ments are not considered defects in material or
workmanship,theyarenotcoveredbytheOriginal
Equipment Warranty. They include, but are not
limited to:
D
calibration of the thermostat
D
adjustment of the doors
D
burner adjustments
D
leveling
D
testing of gas pressure
D
tightening of fasteners.
No installation should be considered complete
without proper inspection, and if necessary, ad-
justment by qualified installation or service per-
sonnel.
To Next Page
Loading...
Need help?
General
