CMC S15 - Battery Pack, Pressure, and Frame Coupling Markings

71 pages

Save Page as PDF

To Next Page

To Previous Page

MAN.161 Rev.7 ENG - Use and maintenance manual S15 page

Picture 55: battery pack (*optional).

Picture 56: battery pack charger (*optional).

Picture 57: list of maximum pressures.

Picture 58: indication of frame coupling.

Main Page

Introduction1
Content of the Manual1
Key for the Symbols Used in this Manual1
Amendments and Integrations3
Specifications4
Technical Sheet4
Performance4
Weight and Pressures4
Identification Plate6
Loading Cycles7
TÜV Certification7
Working Diagram8
Description and Purpose9
Definition9
Machine Purpose9
Description of the Main Components10
MEWP Main Components10
Frame11
Turret11
Pantograph11
Telescopic Boom11
Control Positions12
Machine Switching On/Off Station12
Other Power Supplies *Optional12
Control Station for Engine Switching On/Off12
Platform Control Stations13
Travel Control Station13
Wired Remote Control for MEWP Travel13
Left Track Joystick J113
Outriggers Control Station14
Left and Right Side of Wired Remote Control14
Location for Remote Wired Control14
Platform Operating Control Station15
Buttons/Selectors Group:16
Platform Emergency Control Station18
Emergency Control Station19
Use Procedures20
Environmental Exercise Conditions20
Beaufort Wind Scale20
Safety Distances21
Transport, Storage and Package21
Loading/Uploading through Ramp22
MEWP Use Procedures22
Right Travel Direction22
Loading/Uploading through Ramp by Wired Remote Control22
Placement in the Working Area23
MEWP Stabilization23
Maximum Slopes Allowed in Travel23
Basket Assembly and Access24
Basket Levelling24
Use of the Aerial Part24
Setting the MEWP in the Transport Position24
Battery Pack Recharge25
Battery Pack25
Emergency Operations26
Emergency Button26
Emergency Bypass26
Failure of Hydraulic System26
Aerial Part Recovery27
Stabilizers Recovery27
Insert for Manual Pump27
Hydraulic Distributor Group27
Electropump28
Safety Rules28
Tracks Recovery28
Emergency Electropump28
Before Positioning the MEWP29
During the Positioning of the MEWP29
During the Use of the MEWP30
During the Entrance in the Basket30
Safety Devices32
At the End of the Works32
Electrical Devices32
Hydraulic Devices32
Markings33
MEWP Model Mark33
Switching On/Off Box with Honda Engine34
Switching On/Off Box with Yanmar Engine34
Display34
List of Machine Status35
Wired Remote Control35
Basket Control Station in Full Lithium Version36
Basket Indications36
Maximum Load in Basket36
Turret Indications37
Obligation to Consult the Manual37
Dead man Box for Stabilization/Destabilization38
Warning for Stabilization38
General Obligations and Prohibitions38
Indication of Fuel38
Indication for Oil Refill39
Indication for Engine Oil Checking39
Indication for Engine Oil Adding39
Indication of Minimum/Maximum Oil Level39
Battery Pack Charger40
List of Maximum Pressures40
Indication of Frame Coupling40
Direction Arrows on Tracks for Travel41
Warning for Travel in Slope41
Maximum Slopes and Exact Directions for Travel41
Rules for Emergency Bypass Use41
Exchange Electrovalve42
Maximum Load on Stabilizers42
Warning of Burn Risk42
Generic Advices on the Frame42
Electric Danger43
Crushing and Cutting Hazard43
Prohibition to Wet the Item43
MEWP Use Guideline43
US and CAN Standards Respected44
Inspection Registration44
Electrical System45
Hydraulic System46
Daily Maintenance47
Weekly Maintenance49
Monthly Maintenance49
Quarterly Maintenance50
Maintenance after the First 400 Hours50
Six-Monthly Maintenance50
Biennial Maintenance50
Safety Rules During Maintenance51
Maintenance of Endothermic Engine51
Maintenance of 48 V Electric Engine52
Battery Charger Specifics52
Consumables52
Battery Specifics52
Indications for the Demolition of the MEWP53
Service53
Grease53
Remote Connection System54
Troubleshooting55
Outriggers Red Light Does Not Turn on55
Outriggers Do Not Work55
Platform Levelling Does Not Work55
Engine Start Not Working56
Sealings List57
Overload Tests58
Operating Tests59
Control Register60
Delivery of the MEWP to the First Owner60
Following Ownership Transfers61
Mechanisms Replacement62
Replacement of Structural Elements63
Replacement of Hydraulic Components64
Replacement of Electrical Components65
Replacement of Safety Devices66

CMC S15 - Battery Pack, Pressure, and Frame Coupling Markings

Table of Contents

Related product manuals