E4D Technologies Nevo - New Hardware; New Scanner and Tip Management

Customer Support 800.537.6070 7
New Hardware:
NEVO v5.0 requires a Windows 8 computer and a scanner. Design Center carts can be updated to have a
new computer and a di erent attachment for the new scanner. The scanner can be unplugged and used on
another updated cart or a NEVO laptop.
New Scanner
The new scanner has a removable tip. Press the black release button (below the scanning window) to
separate the tip from the wand. Do NOT just pull on the tip.
Tips are consumable products (approximately 100 high level disinfections) and can be ordered in re lls of 3.
Tip can be removed and disinfected while the next tip is being used. See below for cleaning instructions on
the tip and the system itself.
Icons in the lower-left corner of the screen indicate the status of the scanner.
Disconnected
Connected - Cold
Tip Disconnected
Heating - Stage 1
Heating - Stage 2
Ready
Cleaning the Scanner Tip
For intraoral scanning systems only.
The following instructions are for the removable tip of the scanner. It is not for the entire scanner.
See instructions below for cleaning the base of the scanner.
Chemical Disinfection:
These instructions were validated using MaxiCide Plus w/ Activator (3.4% Gluteraldehyde)
disinfectant available from Henry Schein Dental (#102-2865).
DO NOT Autoclave. DO NOT place in Ultrasonic Cleaner.
1. Clean the tip for 2 minutes under running tap water at 22 - 25°C (4 liters/minute) to remove debris.
2. Test the potency of your activated MaxiCide Plus prior to disinfection. (Recommend MetriTest Strips by
Metrex (HSD #602-3437)
3. Immerse the tip in activated MaxiCide Plus for 120 minutes (2hours).
Do not leave the tips soaking overnight.
4. Remove tip from the disinfectant.
5. Rinse disinfected part in three separate copious amounts of distilled water (1000ml volume of water;
minimum of 2” head height while part is immersed).
6. Agitate the tip in the water for 30 seconds and then let it stand in the water for another 30 seconds.
7. Repeat the agitation and soak in each of the other two containers with fresh distilled water.