FLOWBIRD CWT S5 - Inside the Pedestal

82 pages

Save Page as PDF

To Next Page

To Previous Page

Page 30CWT S5 Installation & Maintenance ManualIssue 5

Product description

Figure 22, inside the cabinet

1. Main board

2. Paper roll

3. Printer

4. Coin validator

5. Escrow

4.7.5

Inside the pedestal

The contents of the pedestal may vary depending on local regulations, needs for

specific electrical components, etc.

Main Page

Table of Contents3
Aprovals6
Introduction6
About this Manual6
Available Formats6
List of Major Changes7
Target Audience7
Structure of this Book7
References7
Terminology8
Safety9
High Voltage9
Batteries9
Back-Up Battery Holder on CPU Board9
Short-Circuit Risk10
Corrosive Acid10
Risk of Explosion10
Disposal11
Display11
Heavy Lifting11
Risk of Tipping11
ESD Protection11
What Is ESD11
Avoiding ESD Damage12
Product Description13
Terminal Interface14
Display Unit15
Means of Payment15
Payment Applications15
Payment Methods16
Mobile Payments16
Cards16
Coins16
Card Readers17
Coin System17
Coin Detection Sensor18
Coin Validator19
Escrow20
Coin Box20
Bar Code Scanner21
Print System21
Flowbird Printer23
Paper Supply23
Printer Mounting23
Pre-Printing on Printer Media24
Data Communication25
Weboffice25
Transaction Processing25
Mechanical Design25
Terminal Measurements25
General27
Product Label28
Inside the Cabinet28
Inside the Pedestal30
COIN BOX Vault31
Door Locks32
Mechanical Locks32
Electronic Locks32
Door-Open Sensors35
Heating System35
Power Supply35
Power Control36
Battery Charging by Solar Power36
Battery Charging by Mains Power37
Administrative Tools37
The Service Menu37
CWT S5 Interconnections38
CPU Board Version 0501-E0153 Rev B38
Installation41
Site Preparations41
Minimal Site Dimensions & Mounting Holes41
Solar Power Positioning42
Placing the Terminal on an Existing Concrete Foundation43
Pouring a New Concrete Foundation44
Power Supply45
Installing the Terminal46
Mounting the Pedestal in Its Foundation46
Mounting the Cabinet on Top of the Pedestal46
Installing the Battery46
Connecting to the Mains Power Grid47
Installing a Modem49
Checking Modem Contact with Network Provider51
Loading Paper in the Flowbird Printer52
Installing the Coin Box56
Program Loading56
Changing the Settings of the Terminal57
Daily Operation57
Changing and Emptying the Coin Box57
Paper Refill58
Maintenance61
Batteries62
Battery Levels62
Battery on CPU Board62
Lead-Acid Batteries63
Battery Replacement63
CPU Board Lithium Cell Replacement63
Replacing the Lead-Acid Battery64
Flowbird Printer64
Correcting Paper Jams in the Printer64
Correcting Paper Jams and Cleaning the Print Head in the Printer64
Printer Replacement66
Coin Unit67
Coin Validator67
Cleaning of the Coin Validator67
Replacing the Coin Validator69
Replacing the Escrow69
Card Readers70
Card Reader Replacement70
Display Module70
Display Module Replacement72
Connecting the Display to the CPU Board74
Bar Code Scanner74
Bar Code Scanner Replacement74
Cabinet & Pedestal75
E-Lock Replacement75
Door Replacement77
Lacquer Touch-Up78
Solar Panel79
Changing the CWT Software and Firmware79
Keyword Index81

FLOWBIRD CWT S5 - Inside the Pedestal

Table of Contents