Hypertherm Koolant Koolers N-Series - Proximity to the Plasma Cutting System; 6 Installation; Checking for Shipping Damage; Transportation

 Installation‐CheckingforShippingDamage 
15
5.2.6 ProximitytothePlasmaCu ttingSystem
TheHyperthermHPR800XDplasmacuttingsystemissuppliedwithastandardhosekitforconnectingthe
processcoolingcircuitwaterfromthechillertotheplasmacuttingsystem.Thechillerlocationmustbeclose
enoughtotheplasma cuttingsystemtoenable connectivitywiththestandardhosekit.

CAUTION
Exceedingthestandardhoselengthscancauseexcessivepressuredropthroughplumbing
systemsthatleadstochillerflowfaultsand/orprematurechillerpumpfailures.
6 Installation
6.1 CheckingforShippingDamage
Upondeliveryofthechilleralwaysverifythattheshipmentmatchesthebilloflading.
Inspectthechillerimmedi ately forsignsofshipping damagebothvisibleandconcealed.Damagedcrati ng
indicateslikelydamage tothechillerandmayrequiretheremovalofthepaneland/orairfilter(s)forfurther
inspection.Refertosectio
n6.4InternalAccesstoremovethepanelorairfilter(s)ofthechiller.
Anydamagemustbereportedtotheshipping carrierandacopyofthedamageclaimsubmittedtoGDTSoryour
salesrepresentative.
6.2 Transportation
Thechillerisshipped inacratewithprotectivepackingandwrappingthatshouldremaininplaceuntiltheunitis
transportedtoitsfinalinstallationlocation.Itisrecommendedthatthechiller(cratedoruncrated)bemoved
withaforklift.

WARNING
Thechillerisheavyandthereisriskoftiltingorfallingwhenmoved.Transportationofthe
chillermustonlybeperformedbytrainedandqualifiedpersonnelusingappropriate
equipment.
Ensurethatthechillerissecurelypositioned(tinesofforkliftspreadasfaraspermittedalong
thechiller’slongedgeandexten
dthoroughlythroughtheoppositeliftingface)beforemoving
thechiller.
Improperhandlingorinsecureliftingofthechillerduringtransportationcancauseittotipand
fallleadingtoinjuryordeath.

WARNING
Thechillerisonlyintendedtobeliftedfromthesides(filterordoor).Liftingthechillerfrom
theends(ElectricalenclosureorplumbingI/O)cancaus eittotipandfallleadingtoinjuryor
death.



Hypertherm, Inc. Part Number: 810540