Hypertherm Koolant Koolers N-Series - 9.2 Inline Heater Temperature Limit Switch; 9.3 Refrigeration High Pressure Switch

 Troubleshooting‐AlarmList
46
Alarm
Code
AlarmName Type Description CorrectiveAction
AL*032 RecircFlowPrbErr
Auto
reset
Theflowsignalfromtheflow
meterintherecirculationcircuitis
readingopen,short,oroutof
range.
 ChecktheM12Eurofastelectricalconnectoron
theflowmetertoensureitisfullytightened.
 IfthefaultpersistscontactDTSService.

AL*033 RecircTempPrbErr
Auto
reset
Thetemperaturesignalfromthe
flowmeterintherecirculation
circuitisreadingopen,short,or
ourofrange.
 ChecktheM12Eurofastelectricalconnectoron
theflowmetertoensureitisfullytightened.
 IfthefaultpersistscontactDTSService.
AL*034 FlitInPressPrbErr
Auto
reset
Thepressuresignalfromfluidfilter
inletpressuretransduceris
readingopen,short,oroutof
range.
 ChecktheM12Eurofastelectricalconnectoron
thepressuretransducertoensureitisfully
tightened.
 IfthefaultpersistscontactDTSService.
AL*035
FiltOutPressPrb
Err
Auto
reset
Thepressuresignalfromfluidfilter
outletpressuretransduceris
readingopen,short,oroutof
range.
 ChecktheM12Eurofastelectricalconnectoron
thepressuretransducertoensureitisfully
tightened.
 IfthefaultpersistscontactDTSService.
AL*036
ProcessPressPrb
Err
Auto
reset
Thepressuresignalfromprocess
outletpressuretransduceris
readingopen,short,oroutof
range.
 ChecktheM12Eurofastelectricalconnectoron
thepressuretransducertoensureitisfully
tightened.
 IfthefaultpersistscontactDTSService.
AL*037
ProcessFlowMeter
Err
Auto
reset
Theflowsignalfromtheprocess
flowmeterisreadingopen,short,
oroutofrange.
 ChecktheM12Eurofastelectricalconnectoron
theflowmetertoensureitisfullytightened.
 IfthefaultpersistscontactDTSService.
AL*038 InletTempPrbErr
Auto
reset
Thetemperaturesignalfromthe
processflowmeterisreading
open,short,oroutofrange.
 ChecktheM12Eurofastelectricalconnectoron
theflowmetertoensureitisfullytightened.
 IfthefaultpersistscontactDTSService.
AL*039
TankLevelSensor
Err
Auto
reset
Thelevelsignalfromtheultrasonic
tanklevelsensorisreadingopen,
short,oroutofrange.
 ChecktheM12Eurofastelectricalconnectoron
thetanklevelsensortoensureitisfully
tightened.
 IfthefaultpersistscontactDTSService.
AL*040 CondTempPrbErr
Auto
reset
Thetemperaturesignalfromthe
condenserthermistorisreading
open,short,oroutofrange.
 ChecktheDeutschelectricalconnectoronthe
thermistortoensureitisfullyinsertedintothe
matingconnectoronthewiringharness.
 IfthefaultpersistscontactDTSService.
AL*041
SuctionTempPrb
Err
Auto
reset
Thetemperaturesignalfromthe
suctionthermistorisreadingopen,
short,oroutofrange.
 ChecktheDeutschelectricalconnectoronthe
thermistortoensureitisfullyinsertedintothe
matingconnectoronthewiringharness.
 IfthefaultpersistscontactDTSService.
AL*042 OutTempPrbErr
Auto
reset
Thetemperaturesignalfromthe
outletfluidthermistorisreading
open,short,oroutofrange.
 ChecktheDeutschelectricalconnectoronthe
thermistortoensureitisfullyinsertedintothe
matingconnectoronthewiringharness.
 IfthefaultpersistscontactDTSService.
AL*043 CondPressPrbErr
Auto
reset
Thepressuresignalfromthe
condenserpressuretransduceris
readingopen,short,oroutof
range.
 Checktheelectricalconnectoronthepressure
transducertoensureitisfullyinsertedintothe
matingconnectoronthewiringharness.
 IfthefaultpersistscontactDTSService.
AL*044 SucPressPrbErr
Auto
reset
Thepressuresignalfromthe
condenserpressuretransduceris
readingopen,short,oroutof
range.
 Checktheelectricalconnectoronthepressure
transducertoensureitisfullyinsertedintothe
matingconnectoronthewiringharness.
 IfthefaultpersistscontactDTSService.
AL*045
AmbientTempPrb
Err
Auto
reset
Thetemperaturesignalfromthe
ambientthermistorisreading
open,short,oroutofrange.
 ContactDTSService.
Hypertherm, Inc. Part Number: 810540