Innovative Technology NV22 - Page 3

NV9 Spectral Range Manual
<< Back to Contents
Copyright © Innovative Technology Ltd 2019 Doc: GA02156 NV9S Range User Manual
Version: 1.1
Page 2 of 54
CASHBOX MOUNTING ............................................................................................................................ 22
4.4.1 Cashbox Removal..................................................................................................................... 22
4.4.2 Cashbox fitting (slide on cashbox) ............................................................................................ 23
4.5 REMOVING THE BLANKING PLATE .............................................................................................................. 24
MOUNTING MULTI NOTEFLOAT ................................................................................................................ 25
REMOVING MULTI NOTEFLOAT ................................................................................................................. 26
5 SOFTWARE INSTALLATION AND CONFIGURATION ................................................................................ 27
5.1 INTRODUCTION..................................................................................................................................... 27
5.2 SOFTWARE DOWNLOADS ........................................................................................................................ 27
5.3 DRIVERS ............................................................................................................................................. 27
DATASET/FIRMWARE PROGRAMMING ........................................................................................................ 27
5.4.1 Validator Manager .................................................................................................................. 27
5.4.1.1 General Description ......................................................................................................................27
5.4.1.2 System Requirements ...................................................................................................................27
5.4.1.3 Hardware Setup ............................................................................................................................28
5.4.1.4 Switching to Programming Mode (SSP) ..........................................................................................28
5.4.1.5 Programming the device ...............................................................................................................28
5.4.2 Updating using a Micro SD card ............................................................................................... 29
5.5 MICRO SD CARD LOGGING ....................................................................................................................... 30
6 ROUTINE MAINTENANCE ...................................................................................................................... 31
INTRODUCTION ..................................................................................................................................... 31
CLEANING THE NV9 SPECTRAL.................................................................................................................. 31
6.2.1 Recommended cleaning intervals ............................................................................................. 31
6.2.2 Cleaning the validator .............................................................................................................. 31
6.2.2.1 Housing assembly cleaning ............................................................................................................31
6.2.3 Lozenge removal and cleaning ................................................................................................. 32
6.2.4 Lozenge fitting ......................................................................................................................... 33
7 PROTOCOLS AND INTERFACING ............................................................................................................ 35
7.1 INTRODUCTION..................................................................................................................................... 35
7.2 SSP AND ESSP ..................................................................................................................................... 35
7.2.1 General Description ................................................................................................................ 35
7.2.2 Pin Assignments ...................................................................................................................... 36
7.2.3 Setup Examples ....................................................................................................................... 37
7.2.3.1 Direct USB cable ...........................................................................................................................37
7.2.3.2 IF17 Set up ....................................................................................................................................37
7.3 CC4 ................................................................................................................................................... 39
7.3.1 General Description ................................................................................................................ 39
7.3.2 ccTalk
®
DES Encryption ............................................................................................................ 39
7.3.3 Pinout ..................................................................................................................................... 40
7.3.4 Setup Example Drawing/s ....................................................................................................... 41
7.3.4.1 Direct UBS Cable ...........................................................................................................................41
7.3.4.2 IF17 Set up ....................................................................................................................................41
7.4 CC2 ................................................................................................................................................... 42
7.4.1 General Description ................................................................................................................ 42
7.4.2 ccTalk
®
DES Encryption ............................................................................................................ 42
7.4.3 Pinout ..................................................................................................................................... 43
7.4.4 Setup Example Drawing/s ....................................................................................................... 44
7.4.4.1 Direct UBS Cable ...........................................................................................................................44
7.4.4.2 IF17 Set up ....................................................................................................................................44
8 FIRST LEVEL SUPPORT ........................................................................................................................... 45
8.1 BEZEL LED FLASH CODES ........................................................................................................................ 45
BEZEL/STATUS LED FLASH CODES ............................................................................................................. 45
8.2.1 NV9 Spectral Bezel Fault codes ................................................................................................. 45
8.2.2 Multi Notefloat Status LED Flash codes .................................................................................... 46