KTM 2016 RC 390 User Manual

21 TROUBLESHOOTING 163
Faults Possible cause Action
Engine overheats Defect in radiator fan system – Check the radiator fan system.
The engine diagnosis warning
lamp (MIL) lights up red
Fault in fuel injection system – Read out the fault memory using the KTM diag-
nostics tool.
Engine dies during the trip Lack of fuel – Refuel. ( p. 70)
Fuse 1, 3, 4, or 7 is blown – Change the fuses of individual power consumers.
( p. 130)
The ABS warning lamp lights up ABS fuse is blown – Change the ABS fuses. ( p. 128)
Large difference in wheel speeds of the
front and rear wheels
– Stop the vehicle, switch off the ignition, and
start it again.
Malfunction in ABS – Read out the ABS fault memory using the KTM
diagnostics tool.
High oil consumption Engine vent hose bent – Route the vent hose without bends or change it if
necessary.
Engine oil level too high – Check the engine oil level. ( p. 151)
Engine oil too thin (low viscosity) – Change the engine oil and oil filter and clean the
oil screens. ( p. 151)
Headlight and parking light are not
functioning
Fuse 6 blown – Change the fuses of individual power consumers.
( p. 130)
Turn signal, brake light, and horn are
not functional
Fuse 6 blown – Change the fuses of individual power consumers.
( p. 130)
Time is not (correctly) displayed Fuse 7 is blown – Change the fuses of individual power consumers.
( p. 130)
– Set the clock. ( p. 54)
Battery discharged Ignition was not switched off when
vehicle was parked
– Recharge the battery. ( p. 125)

KTM 2016 RC 390 Specifications

General

Displacement	373.2 cc
Bore x Stroke	89 mm x 60 mm
Compression Ratio	12.6:1
Power	32 kW (44 hp) @ 9, 500 rpm
Torque	35 Nm @ 7, 250 rpm
Transmission	6-speed
Rear Suspension	WP monoshock
Rear Brake	230 mm disc, single-piston caliper
Front Tire	110/70 ZR17
Rear Tire	150/60 ZR17
Seat Height	820 mm
Fuel Tank Capacity	10 liters
Dry Weight	147 kg
Ground Clearance	178.5 mm
Engine Type	Single-cylinder, 4-stroke
Fuel System	Electronic Fuel Injection
Front Suspension	WP USD 43 mm
ABS	Bosch 9MB Two-Channel ABS
Frame	Steel trellis frame
Front Brake	300 mm disc, 4-piston radial caliper