LS tractor MT563 - Page 247

To Next Page

To Previous Page

7 -1

① Cabin type

(Unit : mm)

7. Dimension and Specification

* When applying front tires: 11.2-24 8PR, rear tires: 16.9-30 8PR

Main Page

Table of Contents11
General Notices for Safety17
Note to the Owner - General Information17
Before Using the Tractor19
Manual Scope and Required Training Level21
Metric and Imperial Units Abbreviations23
Product Identification Number (PIN)25
Operator's Manual Storage27
Tractor Orientation28
Safety Precautions (Read this for Safety before Using)29
Notices before Using the Tractor29
Notices When Starting Engine33
Notices While Operating/Using the Tractor34
Notices When Connecting Implement37
Notices When Towing the Tractor38
Notices When Transporting the Tractor38
Notices When Servicing the Tractor after Work39
Notices When Handling Diesel Fuel40
Notices When Leaving the Tractor41
Notices Relating to Toxic Substances41
Tractor Stability42
Ecology and the Environment45
Symbols47
Safety Decals48
Instructional Decals56
Long-Term Storage59
Preparation for Storage59
Check & Maintenance During Storage60
Preparation for Reuse61
Instruction for Safe Operation63
The Name of each Part63
Boarding and Exiting the Tractor64
Boarding the Tractor64
Seat Adjustment65
Seat Belt67
Tilting Steering Wheel68
Ventilation (Cabin Only)68
Exiting the Tractor69
Safety Device70
Hood (Bonnet)70
Fender70
PTO Safety Cover and Protection Cap70
Roll-Over Protective Structure (ROPS)71
Instruments and Controls73
Instrument Panel and Front Controls73
Instrument Panel74
Key Switch82
Throttle Pedal82
Clutch Pedal83
Shuttle Lever (Synchro-Shuttle)83
Brake Pedals84
Combination Light Switch85
Hazard Warning Light Switch88
Grille Work Light Switch89
DPF Switch90
Beacon Lamp Switch (if Fitted)95
PTO Switch (if Fitted)95
Right-Hand Controls and Cabin Pillar96
Throttle Lever96
Main Gear Shift Lever97
Work Light Switch98
Window Wiper&Washer Switch (Cabin Only)99
Electrical Power Outlet Socket (Cabin Only)100
Indoor Light (Cabin Only)100
Audio Player (Cabin Only) (if Fitted)100
4WD Switch101
Parking Brake Lever101
Differential Lock Switch102
PTO Mode Switch (Optional)103
PTO Switch104
Engine Speed Cruise Control (ESC) Switch105
Left-Hand Controls107
Range Gear Shift Lever107
Creeper Gear Lever (if Fitted)108
PTO Gear Lever108
Passenger's Seat (if Fitted)109
Power Shuttle System (PSS) (if Fitted)110
Power Shuttle Lever (PSS)110
Clutch Pedal (PSS)112
Clutch Button (PSS)113
CAL/SEL Switch (PSS)113
Engaging Speed +/- Switch (PSS)114
Error Diagnosis Code (PSS)115
Hydraulic System117
Safety Precautions117
Steering System118
Hydraulic Lift Control (MHL)119
Remote Control Lever and Quick Coupler (Optional)122
Joystick Lever (Optional)123
Auto Lift Control (MHL, if Fitted)124
Hydraulic System Diagram125
Operation and Work127
How to Handle New Tractor127
Check Points127
Notices in Handling New Tractor (Engine Brake-In Procedure)127
Engine Start and Stop128
Engine Start128
Start in Cold Weather130
Engine Stop130
How to Drive and Stop131
Transmission Warm-Up in Cold Weather131
How to Drive132
Changing Speed134
Emergency Stop134
Stopping Tractor135
Parking136
Handling Turbocharger (if Fitted)136
Transport on Public Roads (1) Safety Rules When Driving Tractor on the Roads137
Light Operation138
7-Pole Connector (Optional)139
Notices When Towing the Tractor140
Notices When Transporting the Tractor142
Field Operations143
Rear 3-Point Linkage143
Power Take-Off (PTO) Operation147
Hitch and Drawbar (Optional)151
Technically Maximum Permissible Mass152
Tires and Load Capacity153
Adjusting Wheel Tracks and Tire Replacement154
Using Front-End Loader (if Fitted)159
Adjusting Steering Angle162
Recommended Maximum Specification of Implements163
Ballasting Weights (Optional)164
Working in Hazardous Area167
Driving Speed168
Lubrication and Maintenance171
General Information171
Tightening Torque for Normal Assembly172
Standard Torque Data for Hydraulics174
General Specification - Diesel Fuel177
Biodiesel Fuel178
Refueling the Tractor180
Change Engine Coolant to Organic Acid Technology (OAT) Coolant181
Access for Maintenance182
Maintenance Chart183
Lubricants and Capacity185
First 50 Hour Check186
When the Warning Indicator Lights187
Drain Water from Fuel Filter187
Engine Oil Pressure Indicator188
Battery Charging Indicator188
Check before Starting (Daily Check)189
Engine Oil189
Fuel Tank190
Instrument Panel & Indicators190
Engine Coolant191
Air Cleaner (Dry Type)192
Cleaning of Radiator and Radiator Screen193
Adjustment of Clutch Pedal Play195
Adjustment of Brake Pedal Play196
Every 50 Hour Check197
Lubricating Grease Nipple197
Cleaning Radiator and Radiator Screen197
Checking Transmission Oil198
Checking Front Axle Oil198
Battery Check199
Air Cleaner (Dry Type)199
Hydraulic Hoses and Leakage199
Cleaning Cabin Air Filters199
Every 100 Hour Check200
Checking and Adding Engine Oil200
Every 300 Hour Check201
Replacing Engine Oil and Filter201
Replacing Hydraulic Oil Filter202
Replacing Power Shuttle Oil Filter (if Fitted)202
Checking Brake Oil203
Tension Adjustment of Fan Belt204
Toe-In204
In-Line Pressure Filter (if Fitted)204
Cleaning Fuel Tank205
Every 500 Hour Check206
Changing Front Axle Oil206
Changing Transmission Oil207
Replacing Fuel Filter Cartridge208
Replacing Cabin Air Filters209
Every 1000Hr or 1-Year Check210
Replacing Air Cleaner Element (Dry Type)210
Adjusting Engine Valve Clearance211
Checking Nozzle Injection Pressure211
Every 1500Hr or 2-Year Check212
Replacement of Engine Coolant212
Cleaning Emission Related Parts215
Every 3000Hr Check216
Cleaning Emission Related Parts216
General Maintenance (When Required)217
Air-Bleeding from Fuel System217
Air-Bleeding from Brake Lines220
Air-Bleeding from Clutch Line (Synchro-Shuttle Models Only)220
Fuse & Main Fuse221
Battery Handling and Notices224
Alternator and Drive Belt - Check228
Turn Signal Light Bulb- Replace229
Headlight Bulb - Replace230
Touch-Up Paint Color231
Troubleshooting232
Air Conditioning System (Cabin Type)237
The Name of each Part of Cooling and Heating System237
How to Use Air Conditioner and Heater238
How to Operate Air Conditioner and Heater238
Every 6 Month Check239
Checking Refrigerant Amount239
Cleaning Condenser and Radiator Screen239
Checking Leakage239
Belt Tension Adjustment240
Cleaning and Replacing Cabin Air Filters240
Every Year Check241
Compressor Check241
Control Switch Check241
Using Cut-Off Valve (if Necessary)242
Troubleshooting243
System Diagram245

LS tractor MT563 - Page 247

Table of Contents

Related product manuals