Manitowoc Grove GRT9165 Service Manual

1-3
Published 10-01-2020 Control # 699-00
GRT9165 SERVICE MANUAL INTRODUCTION
1
GROVE
LIST OF SPECIFICATIONS
General
Model . . . . . . . . . . . . . . . . . . . . . . . . . . . . GRT9165
Full Vision Cab . . . . . . . . . . . . . . . . . . . . 20° cab tilt
Rated Capacity. . . . See Load Chart Manual in cab
Drive. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 x 4 x 6
Gross Weight . . See Axle Weight Distribution Table
Dimensions
NOTE: Dimensions listed are for a crane with all
components fully retracted in the travel mode.
Wheelbase . . . . . . . . . . . . . . . . . 5000 mm (197 in)
Overall Crane Length . . . . . . 16021 mm (630.75 in)
Compact Transport Length. . . . . . . (8.5 m) (27.9 ft)
Overall Crane Width
with Counterweight . . . . . . . 3996 mm (157 in)
without Counterweight. . . . 3800 mm (149.6 in)
Overall Crane Height
Ride Height . . . . . . . . . . . 3792 mm (149.29 in)
Fully Lowered . . . . . . . . . 3741 mm (147.29 in)
Outside Turning Radius
(with Jib Installed)
2 Wheel Steer (in meters) . . .19.7 m (64 ft 8 in)
6 Wheel Steer (in meters) . . .15.0 m (49 ft 3 in)
Outside Turning Radius
(without Jib Installed)
2 Wheel Steer (in meters) . . .19.0 m (62 ft 4 in)
6 Wheel Steer (in meters) . . .14.4 m (47 ft 3 in)
Outside Curb Clearance
2 Wheel Steer (in meters) . . .15.6 m (51 ft 2 in)
6 Wheel Steer (in meters) . . .10.6 m (34 ft 9 in)
Capacities
Fuel Tank (Usable) . . . . . . . . . . . . . . 271 L (72 gal)
Engine Cooling System . . . . . . . . . . 42 L (11.1 gal)
Engine Cooling System (Liquid Coolant
Conditioner . . . . . . . (test and add, as necessary)
Engine Crankcase with filter (Tier 4) . . 15 L (4 gal)
Hydraulic Tank (Reservoir Capacity)
Total. . . . . . . . . . . . . . . . . 838.58 L (221.5 gal)
Full Level. . . . . . . . . . . . . . . . 729 L (192.6 gal)
Hoist Drums (each) . . . . . . . . . . . . . . . . 4 L (1 gal)
Swing Drive Gearboxes (each) . . . . . . . 4 L (4.2 qt)
Swing Drive Gearbox Brake
Assemblies (each) . . . . . . . . . . . . . 0.3 L (0.6 pt)
Axle Planetary Hubs and Wheel
Bearings (each wheel end). . . . . . 9.8 L (10.4 qt)
Axle Differentials (each) . . . . . . . . .44.8 L (11.8 gal)
Transmission (includes Torque
Converter . . . . . . . . . . . . . . . . .44.5 L (11.75 gal)
Diesel Exhaust Fluid (DEF) Tank . . . 37.9 L (10 gal)
Transmission
Gear Ratios — Forward and Reverse
Low Range
1st . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12.64:1
2nd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.11:1
3rd. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2.25:1
High Range
4th . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4.30:1
5th . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2.08:1
6th . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0.76:1
Torque Converter
Stall Ratio. . . . . . . . . . . . . . . . . . . . . . . . . . . 1.784:1
Charge Pump
Capacity . . . . 80 L/min (21 gal/min) @ 2000 rpm
Engine
Cummins QSB 6.7L - Stage V/Tier 4F
Type . . . . . . . . . . . . . . . . . . . . . . . . . 4-cycle, Diesel
with After-Treatment System
6-cylinder Turbocharged . . . .After-Cooled Engine
Horse Power Rating. .224kW (300 hp) @ 2500 rpm
Maximum Speed, No Load . . . . . . . . . . . 2700 rpm
Max. Torque . . . . .1288 N·m (950 lb-ft) at 1500 rpm
24 Volt Electrical System . . . . two 12 Volt Batteries
Fuel . . . . Maximum 15 ppm sulfur content (ULSD)
plus Diesel Exhaust Fluid (DEF)
Cummins QSB 6.7L - Non-Certified
Type . . . . . . . . . . . . . . . . . . . . . . . . . 4-cycle, Diesel
6-cylinder Turbocharged . . . . After-Cooled Engine
Horse Power Rating. .224kW (300 hp) @ 2500 rpm
Maximum Speed, No Load . . . . . . . . . . . 2700 rpm
Max. Torque . . . . .1288 N·m (950 lb-ft) at 1500 rpm
24 Volt Electrical System . . . . two 12 Volt Batteries
Fuel . . . . . . . . . Maximum 5000 ppm Sulfur Diesel
Axles
Total Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . 36.84:1
Carrier Ratio . . . . . . . . . . . . . . . . . . . . . . . . . 6.14:1
Planetary Ratio . . . . . . . . . . . . . . . . . . . . . . . . . 6:1
Steering
Type . . . . . . Independent Hydraulic Power Steering
Front axle. . . . . . . . . . controlled via steering wheel
Rear axles . . . . . . . . . . . . .mechanically linked and
controlled via separate switch in cab
Rear steer . . . . . . . . . alignment indicator included
Coordinated Turning Radius
Outside 6 Wheel Steer . . . . . . .10.2 m (22.5 ft)
Inside 6 Wheel Steer. . . . . . . . . .7.4 m (24.2 ft)
Brakes
Type . . . . . . . . . . . . . . . 6 Wheel Hydraulic Dry Disc
Acting on all Wheels w/ Dual Calipers
Parking. . . . . . Front Axle Mounted, Spring Applied
Hydraulic Released
Wheels and Tires
Lugs per Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Torque . . . . . . . . .610 to 678 N·m (450 to 500 lb-ft)
Tire Size. . . . . . . . . . . . 26.5 x 25, 44 bias ply rating
NOTE: For roading and lifting pressures, refer to the
Load Chart Manual in the cab.
Swing Gearbox
Reduction Ratio . . . . . . . . . . . . . . . . . . . . . . . 37.5:1
Continuous Torque. . . . . . . . . . . 381 N·m (281 lb-ft)
Maximum Torque . . . . . . . . . . . .762 N·m (562 lb-ft)

Manitowoc Grove GRT9165 Specifications

General

Brand	Manitowoc
Model	Grove GRT9165
Category	Construction Equipment
Language	English