Manitowoc Grove GRT9165

MAINTENANCE AND LUBRICATION GRT9165 SERVICE MANUAL
9-2
Published 10-01-2020 Control # 699-00
Grove recommends the use of Standard lubricants for Grove
cranes operating in regions where moderate ambient
temperature, humidity, and atmospheric conditions prevail.
These Standard lubricants are effective in ambient
temperatures down to -9°C (+15°F).
Cold weather temperatures below -9°C (+15°F) are
considered arctic. Grove recommends the use of Cold
Weather lubricants for Grove cranes operating in arctic
conditions.
In regions where Grove cranes are operating with arctic
conditions down to -29°C (-20°F), Grove recommends the
use of the Cold Weather lubricants found in Table 9-2.
In regions where Grove cranes are operating with arctic
conditions down to -40°C (-40°F), Grove recommends the
use of the Cold Weather lubricants found in Table 9-3.
NOTE: All fluids and lubricants may be purchased by
contacting an authorized Grove distributor or
Manitowoc Crane Care Parts Department.
Standard Lubricants
Standard lubricants are used on all Grove cranes. Cranes
can also be ordered with Cold Weather lubricants. The
Standard lubricants listed in Table 9-1 are effective in
ambient temperatures down to -9°C (+15°F).
CAUTION
Possible Equipment Damage!
The multipurpose grease installed during manufacture of
this crane contains a lithium base.
Do not apply chassis grease lubricants with air pressure
devices, as chassis contains sealed fittings.
Use of non-approved lubricant may damage components
and/or invalidate published lubricant intervals.
Failure to follow this instruction may cause damage to
equipment.
Table 9-1 : Standard Lubricants [Down to -9°C (+15°F)]
Lubricant/Fluid Grove Spec.
Recommended Lubricant
Type Grade Classification
Extended Service Interval
Axle Gear Oil
6829012964
Century Unigear Semi-synthetic
Texaco Multigear SS
Chevron DELO Gear Lubricant
80W-90 GL-5
Engine Oil (SAE)
(EO 15W-40)
6829104182
Conoco Fleet Supreme EC
Mobil Delvac 1300 Super
Mobil Delvac MX ESP
15W-40 CJ-4
Hydraulic/Transmission Oil 6829006444
Phillip 66 PowerTran XP
Exxon Mobil 424
ISO 46/68
Must meet John
Deere Standard
JDM J20C
Extreme Pressure
Hoist Gear Oil
Swing Drive Oil
6829100213
Mobil Mobilgear 600XP
150 Gear Oil
Texaco Meropa 150
Phillips 66 Extra Duty Gear Oil
AGMA EP-4
AGMA No. 4 EP
Extreme Pressure
Multipurpose Grease
(EP-MPG)
6829003477
Citgo Lithoplex MP# 2 (red)
Chevron Starplex EP-2 (red)
Phillips 66 Multiplex Red (red)
Mobil Mobilgrease XHP 222
(dark blue)
IPIFLEX LI-COMP EP2 (red)
Renolit Hi-Temp 220 (Ivory)
NLGI 2 GC-LB Certified
Open Gear Lube
(EP-OGL)
6829102971 Fuchs Ceplattyn 300 Spray NLGI 1-2