© Precor Incorporated, Unauthorized Reproduction and Distribution Prohibited by Law Page 1
Contents
Section 1 - About This Document ........................................................................................... 5
Section 2 - General Information ............................................................................................. 6
GEN-06/ TRM10 Treadmill Base ......................................... 6
Lubricants ........................................................... 6
Electrical Requirements .............................................. 6
Section 3 - Safety Guidelines ................................................................................................... 8
Section 4 - Operation Verification .......................................................................................... 9
Operation Verification ............................................... 9
Procedure ................................................................................................................................ 9
Operation Verification Checklist .................................... 11
Section 5 - Standardized Service Access Codes ................................................................... 12
Service Access Codes ................................................ 12
Accessing the Service Software ...................................... 12
P80 Console ........................................................................................................................... 13
Access Code Table ................................................... 14
P20 Console Service Software Access ................................. 15
Hardware Validation - Diagnostic Tests (51765761) ................... 16
Club Parameter - Settings (5651565) ................................. 17
Information Display (65) ............................................ 18
Section 6 - Theory Of Operation ........................................................................................... 19
Consoles ............................................................ 19
Basic operation of a console ............................................................................................. 19
Consoles that could appear on the GEN-06 / TRM10 Treadmill Base ........................ 20
Console To Base Communication ....................................... 22
Treadmill Base Operation ............................................ 23
Power Entry ............................................................................................................................ 23
Lower Electronics Module .................................................................................................. 24
AC Drive Motor Controller .................................................................................................. 25
Auto-Stop ............................................................................................................................... 27
AC Lift System – Motion Control ........................................................................................ 28
AC Lift System – Position Monitoring ................................................................................. 30
Section 7 - TRM Base Troubleshooting Procedures ........................................................... 31
Introduction to Treadmill Troubleshooting ........................... 31
Troubleshooting Tripped Breakers .................................... 31
If the unit trips the wall breaker: ........................................................................................ 32
If the Treadmill breaker (power switch) is tripped: ......................................................... 33
Troubleshooting No Power to the Console ............................. 35
Standardized Error Codes ............................................ 36
Error Codes ............................................................................................................................ 38
Error Code Table ................................................................................................................... 39
Validating the Reported Failure ........................................................................................ 40
To Next Page
Loading...
Need help?
General