B
PERIODIC SERVICE SCHEDULE
Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
133
Repair and Service Manual
10002660
PERIODIC SERVICE SCHEDULE
PSS
C - CHECK C&A - CHECK & ADJUST CL - CLEAN R - REPLACE
REMARKS
Before each use DAILY
DAILY
WEEKLY
20 hrs
MONTHLY
50 hrs
QUARTERLY
125 hrs
SEMI-ANNUAL
250 - 300 hrs
ANNUAL
5 YEARS
Tires - Check pressure and inspect condition of tires & rims. C C C C C C
Hardware - Check for loose or missing. C C C C C C
Overall Vehicle Condition C C C C C C
Battery Pack - Check state of charge, condition, loose terminals, corrosion,
hold down & hardware.
C C CL CL CL CL
Brake Pedal - Check for smooth operation C C C C C C
Accelerator - Check for smooth operation. C C C C C C
Charger / Receptacle - Inspect charger connector and receptacle. C C C C C C
Brakes - Conduct brake performance test; adjust if required. C&A C&A C&A C&A
Wiring - Inspect for loose connections, broken or missing insulation. C C C C
Steering Assembly - Check for excess play, loose or missing hardware. C C C C
Tie Rods - Check for excess play, bent rods, loose or missing hardware. C C C C
Front Axle - Check for damage to axle, loose or missing hardware. C C C
Rear Axle - Noise, loose or missing hardware. C C C C
Front and Rear Differential- Check for leaks, drain & replace fluid. C C C C R
Rear Suspension - Inspect for strut oil leakage, worn bushings, excessive play
in hubs, loose or missing hardware.
CCC
Front Suspension - Inspect for strut oil leakage, excessive play in hubs or
kingpins, worn bushings, loose or missing hardware.
CCC
Front Wheel Alignment - Inspect for unusual tire wear. C&A C&A C&A
Steering Assembly - Inspect bellows and pinion seal for damage and leakage. C C
Rack End Ball Joint - Check for noise and loose or missing hardware. C C
NOTE: Some maintenance items must be serviced more frequently on vehicles used under severe driving conditions.
To Next Page
Loading...