Table of Contents
1
i
1 General Information
How To Use This Manual...................................................................................... 1-1
Important Repair Information................................................................................ 1-2
10 Maintenance and Safety
Lockout Procedure
Lockout Procedure...........................................................................................................10-1
Adjust Drive Belt
Adjust Drive Belt ...............................................................................................................10-2
Brake Maintenance Procedures
Brake Bleeding Procedure (Front) ..................................................................................10-5
Brake Bleeding Procedure (Rear) ...................................................................................10-6
Brake Bedding ..................................................................................................................10-7
Key Programming
Key Programming .............................................................................................................10-8
Motor Commissioning
Motor Commissioning ................................................................................................... 10-10
Motor Controller Firmware Update
Motor Controller Firmware Update............................................................................... 10-14
20 Power Pack
Power Pack
Power Pack .......................................................................................................................20-1
BMS (Battery Management System) [Before 2022MY] .................................................20-6
Battery Management Unit (BMU) [22MY Onwards].................................................... 20-14
Power Pack Battery Signal Harness [Before 2022MY]............................................... 20-15
Power Pack Accessory Power Bus [Before 2022MY]................................................. 20-20
Power Pack Heat Sink Skins [Before 2022MY]........................................................... 20-28
Service Cover [22MY Onwards].................................................................................... 20-31
Front Cover [22MY Onwards] ....................................................................................... 20-31
Rear Cover [22MY Onwards] ........................................................................................ 20-32
Mid Pack Protection Unit [22MY Onwards]................................................................. 20-32
Top Cover [22MY Onwards] ......................................................................................... 20-33
Cooling Fan [22MY Onwards]....................................................................................... 20-34
Assembly Cell Management Unit (CMU) [22MY Onwards]........................................ 20-35
Power Leads - Positive & Negative [22MY Onwards].................................................. 20-37
Contactor [22MY Onwards] .......................................................................................... 20-38
Controller BUS Set [22MY Onwards] ........................................................................... 20-39
12 Volt Harness [22MY Onwards] ................................................................................ 20-41
BCB Main BUS Set [22MY Onwards]........................................................................... 20-42
To Next Page
Loading...
