Case W14 - Page 75

INTERVAL
SERVICE
INSTRUCTIONS
Every 500 Hours
Change first and second stage fuel filters and fuel
See page 95
transfer pump filter.
Check tension of drive belts.
See pages 89
Inspect ROPS system.
See page 20
Clean electric fuel pump filter.
See page 95
Change hydraulic oil filter. (Machines with
See page 107
*P.I.N. 9141518 and after).
Change transmission filter.
See page 115
Every 1000 Hours or
Change hydraulic oil filter (Machines before
See page 104
6 Months Whichever
*P.I.N.9141518).
Comes First
Change hydraulic oil.
See page 104 or 109
Clean hydraulic reservoir suction screen.
See page 105 or 109
Change transmission oil.
See page 115
Clean transmission oil strainer.
See page 115
Clean transmission breather.
See page 116
Change front and rear axle oil.
See page 118
Clean air compressor cylinder head (by dealer
-----
only).
Every 2000 Hours or
Clean and refill cooling system.
See page 87
Yearly, Whichever
Comes First
Check refrigerant.
See page 129
Disassemble and clean alcohol evaporator and
-----
replace all gaskets (by dealer only).
Every 3000 Hours
Rebuild/replace air compressor (by dealer only.)
-----
As Required
Service air cleaner when restriction indicator
See page 84
shows red signal band.
After wheel has been removed for servicing and
See page 131
reinstalled, check wheel nut torque every two
hours until stabilized.
Each time bucket is removed and reinstalled,
-----
torque bucket pin bolts.
Check refrigerant (cab machines) when loss
See page 129
of cooling is noticed.
*Product Identification Number (see page 24).
73