EMKO TRANS MINI AUTO - General Specifications; Maintenance; Order Information; 1 Introduction

1.Introduction
Theunitprovidesautomaticstartandstoptheengineandprotectthegeneratorsystem.Both
automaticandmanualcontrolispossible. A testmodeisalsoavailablewhichallowsthe
generatortoberunforcheckingthegeneratorsystem.
(supportedECUs:VolvoEMS2,VolvoEDC4,
Perkins,ScaniaS6andstandardmessages).
TheunitcalculatesengineRPMfromMagneticPickupsensorinput(Trans-MiniAUTO.MPU
devicesonly)and/orgeneratorvoltagesignal. At Trans-MiniAUTO.CANdevices,unitgets
engineRPMinformationfromJ1939ECUand/orgeneratorvoltagesignal.
TheunitmonitorsJ1939ECUmessagesandprovidesremotestart/stopcontrolviaJ1939
protocolatonly Trans-MiniAUTO.CANdevices.
The unit is extensively programmable through the front panel, with password protection on two
levels. Operational parameters can also be monitored and controlled from a PC via a built-in RS-
232 communication port.
In the event that the engine fails to start on the first attempt, the attempt will be repeated a
programmed number of times or until successful.
The unit monitors generator operation and gives warning of any faults that are detected.
If a fault is detected, the unit shuts down the engine and shows the failure message on the LCD
display.
The unit has Remote Start input for remote control of the engine.
The configurable inputs can be programmed to perform 28 different functions.
1.1GeneralSpecifications
1.2Warranty
EMKO Elektronik warrants that the equipment delivered is free from defects in material and
workmanship. This warranty is provided for a period of two years. The warranty period starts from
the delivery date. This warranty is in force if duty and responsibilities which are determined in
warranty document and instruction manual performs by the customer completely.
1.3Maintenance
Repairs should only be performed by trained and specialized personnel. Cut power to the device
before accessing internal parts.
Do not clean the case with hydrocarbon-based solvents (Petrol, Trichlorethylene etc.). Use of
these solvents can reduce the mechanical reliability of the device. Use a cloth dampened in ethyl
alcohol or water to clean the external plastic case.
4
1.4OrderInformation
Trans-MiniAUTO :
Trans-MiniAUTO.CAN :
Trans-MiniAUTO.MPU :
AutoStartGenSetcontroller,LCDdisplay
AutoStartGenSetcontroller,CanBusJ1939ECUcomm.
AutoStartGenSetcontroller,
speedsensingfromMagneticPickup
Note: Deviceshavetimeclock.Ifrealtimeclockisneeded,“RTC”expressionmustbeaddedtoendofordercode.
Example: Trans-MiniAUTO.MPU.RTC