MDE-3893P Encore® and Eclipse® Series Owner’s Manual · December 2011 Page 39
Periodic Inspections Maintaining Units
Once a month,
after drive-offs,
or as notified
about a potential
leak
Leaks, within
the lower
hydraulics
cabinet
1. Whenever possible, Gilbarco recommends
removing power to the unit before performing
these inspections.
2. Block the unit area to prevent customers from
operating the unit during inspection.
3. Remove the lower panels slowly and carefully to
avoid any fuel being sprayed in the cabinet
(especially if a drive-off has occurred). Wear eye
protection.
4. Inspect all hydraulic connections and seals,
including the following:
• Meters
• Valves
5. If wetness or dripping fuel is found, stop using the
unit, and make arrangements to repair the leak.
Note: Some staining of parts around seals is
normal and does not indicate a problem.
Look for dripping or wet surfaces.
6. Monitor repaired places closely.
• Owner—Inspect
• ASC/CSC only—Repair
and test
CAUTION
To prevent injury when inspecting self-contained
units (equipped with pumps and electric motors), do
not place your hands near the belts, pulleys, or
motors. Do not allow anyone to use either side of the
pump when inspecting. Block the pump/dispenser off
or lock the nozzle to the nozzle hook.
WARNING
CAUTION
If you find a leak, stop using the pump/dispenser, and contact
your local ASC/CSC. Fire, explosion, or electrical shock could
result, if you continue to use a damaged pump/dispenser.
WARNING
CAUTION
Do not attempt to make these repairs yourself. Doing so could
result in severe injury or death.
WARNING
To prevent potential injury, wear eye protection when
performing these inspections.
CAUTION
New
Installations—
After 50,000
gallons (200,000
liters), or after
one month
Filter change
and strainer
cleaning
Replace filters, and clean strainers regularly.
Note: Water alert filters may fail prematurely if water
passes through them.
Only an ASC/CSC must
perform these tasks.
Recommended
Frequency Components Recommended Maintenance
Who Performs the
Inspection/Repair
To Next Page
Loading...
