Global 5120 - Standard Features and Options

GlobalPowerTechnologies  1-3
5120
1.1.1 Health and Safety
Correctoperationandmaintenanceaccordingto this manual is critical for properequipment
functionandsafety.Keepthefollowinginmindwhenusingtheseinstructions.
1.1.2 Warnings
ThroughoutthismanualyouwillnoticeparagraphsprecededbythetextWarning.Itisimpera-
tivethattheadviceintheseparagraphsbeadheredtoasfailuretodosomayresultinpersonal
injuryordeathandpossibledamagetotheequipmentand/orproperty.Warningswillbeprinted
inboldtextinitalicswiththetitleWARNINGincapitalletters.
1.1.3 Cautions
ThroughoutthismanualyouwillnoticeparagraphsprecededbythetextCaution.Itisimpera-
tivethattheadviceintheseparagraphsbeadheredtoasfailuretodosomayresultindamage
totheequipment.CautionswillbeprintedinboldtextinitalicswiththetitleCaution.
1.1.4 Notes
Throughoutthismanual you willnoticeparagraphspreceded bythetextNote.  Thesepara-
graphsprovideadditionalinformationorreferenceothersectionsofthemanual,whichmaybe
useful.Noteswillbeprintedinitalics.
1.2 Standard Features and Options
1.2.1 Standard Features
TheTEGcomesstandardwithafuelpressureregulatorcapableofacceptingupto172kPa
(25psi)andabuiltinfuellter,anAutomaticSparkIgnitionSystem(SI),andlowvoltagealarm
contacts(VoltageSensingRelayorVSR)
1.2.2 Options
Availableoptionsforthe5120ThermoelectricGeneratorareasfollows:
Automatic Shut-O Option (SO):TheAutomaticGasShut-O󰀨option(SO)isdesignedtoturn
o󰀨thegassupplytotheburneriftheameintheTEGisextinguishedandcannotbesubse-
quentlyre-ignitedbytheautomaticSIsystemwithinapproximatelythreetoveminutes.
Corrosive Environment Fuel System Option (SS):TheCorrosiveEnvironmentFuelSystem
is specially constructed with increased corrosion resistant components.  All of the standard
brassttingsandgaugeinternalsarereplacedwithstainlesssteelequivalentswherepossible
andthefuelregulatorisupgradedtocomplywithNACEstandardMR-01-75(SulphideStress
Cracking Resistant Material For Oileld Equipment).  External components that can not be
replacedarecoatedwithGlyptaltoreducetheirriskofcorrosion.