Linde H30D - Determination and Assessment of Hazards from Use of Industrial Trucks

2 Safety
Determination and assessment of hazards from use of industrial trucks
test results must be entered in a "certificate
regarding the analysis of the diesel engine
exhaust gases" and enclosed with the report
book.
Determination and assessment of hazards from use of industrial
trucks
Hazard Action
Check note
X = actioned
-=not
concerned
Notes
Industrial truck
equipment does not
comply with local
provisions
Check
If in doubt, consult
competent factory
inspectorate or
employers’ liability
insurance association
Lack of skills and
qualification of driver
Driver training (sit-on
and stand-on industrial
trucks)
UVV-BGV D 27 - § 7,
BGG 925 driver permit
VDI 3313
Lack of skills and
qualification of driver
Instruction for pedestrian-
controlled trucks
Usage by unauthorised
persons
Access with key only for
appointed staff
Industrial truck not in a
safe condition
Recurrent testing and
rectification of defects
UVV-BGV D 27 - §§ 9,
37, BGG 918
Impaired visibility
through load
Deployment planning
UVV-BGV D 27 - § 12
Contamination of
respiratory air
Assessment of diesel
exhaust gases
TRGS 554
Contamination of
respiratory air
Assessment of fuel gas
exhaust gases
MAK list (maximum work-
place concentrations list)
Impermissible usage
(improper usage)
Issue of operating
instructions
UVV-BGV D 27 - § 5
Impermissible usage
(improper usage)
Written notice of
instruction to driver
UVV-BGV D 27 - §7
Impermissible usage
(improper usage)
UVV-BGV D 27, observe
operating manual and
VDMA leaflet
When filling up with a)
diesel
UVV-BGV D 27, observe
operating manual and
VDMA leaflet
12 Operating Instructions – 393 807 1001 EN – 08/2008