Technical Information
4
G1000 / G2000 Dishwashers
G1000 / G2000 Dishwashers - Table of Contents (Continued)
5.4.3 Flowmeter (circuit board) – Removal .........................................................................................................84
5.4.4 Top Spray Arm Removal.............................................................................................................................84
5.4.5 Middle Spray Arm Removal .......................................................................................................................84
5.4.6 Bottom Spray Arm Removal.......................................................................................................................85
5.4.7 Feed Pipe with Turbidity Sensor – Top Spray Arm, Removal....................................................................85
5.4.8 Feed Pipe – Middle Spray Arm, Removal...................................................................................................85
5.4.9 Spray Arm Sensor Removal........................................................................................................................85
5.4.10 Water Inlet Mixer with Resin Chamber – Removal ....................................................................................86
5.4.11 EGS Valve Solenoid - Removal..................................................................................................................88
5.4.12 Reactivation Valve – Removal ....................................................................................................................88
5.4.13 Salt Container - Removal ............................................................................................................................89
5.4.14 Circulation Pump - Removal.......................................................................................................................89
5.4.15 Circulation Pump - Service .........................................................................................................................91
5.4.15.1 Pump Cap Removal / Heater Element – Access .......................................................................92
5.4.15.2 Slide Shutter Removal ..............................................................................................................92
5.4.15.3 Drive Removal...........................................................................................................................93
5.4.15.4 Pump Impeller Removal ...........................................................................................................95
5.4.15.5 Pump Housing Removal ...........................................................................................................95
5.4.15.6 Capacitor Removal....................................................................................................................95
5.4.15.7 Heater Pressure Switch Removal ..............................................................................................95
5.4.15.8 Speed Sensor Removal..............................................................................................................95
5.4.16 Drain Pump Removal .................................................................................................................................96
5.4.17 Float Switch Removal................................................................................................................................96
5.4.18 Sump Removal ...........................................................................................................................................97
5.4.19 NTC Temperature Sensor Removal...........................................................................................................98
5.4.20 Filter Combination Dismantling.................................................................................................................99
5.4.21 Filter Combination Assembly (New Micro Fine Filter and Handle)........................................................100
5.4.22 Filter Combination Assembly (with Locking Piece)................................................................................101
5.5 Electronic Unit.......................................................................................................................................................103
5.5.1 Mains Switch Removal (Integrated).........................................................................................................104
5.5.2 Electronic Unit Holder Removal..............................................................................................................105
5.5.3 Electronic Unit Removal (Integrated) ......................................................................................................105
6.0 FAULT DIAGNOSIS .................................................................................................106
6.1 Diagnostic Modes – Overview .............................................................................................................................106
6.1.1 Water Hardness Setting – Checking and Programming ...............................................................................107
6.2 Advanta Series.......................................................................................................................................................107
6.2.1 Advanta Series - G2020................................................................................................................................107
6.2.1.1 G2020 - Programming Mode....................................................................................................107
6.2.1.2 G2020 - Service Mode ..............................................................................................................112
6.2.1.3 G2020 Component Test – Information .....................................................................................115
6.2.2 Advanta Series – G2170...............................................................................................................................117
6.2.2.1 G2170 - Programming Mode ....................................................................................................117
6.2.2.2 G2170 - Service Mode ..............................................................................................................124
6.2.2.3 G2170 Component Test – Information .....................................................................................127
6.3 Inspira Series .........................................................................................................................................................129
6.3.1 Inspira Series - G2140 & G2150..................................................................................................................129
6.3.1.1 G2140 / G2150 - Programming Mode ......................................................................................129
6.3.1.2 G2140 / G2150 Service Mode...................................................................................................134
6.3.1.3 G2140 / G2150 Component Test - Information ........................................................................137
To Next Page
Loading...
