Onicon D-100 - Section 1; Default Chapter; Table of Contents

1500 North Belcher Road, Clearwater, FL 33765 • Tel (727) 447-6140 • Fax (727) 442-5699 • sales@onicon.com
D-100 Flow Display Manual 08-12 - 0634-7 Page 3
TABLE OF CONTENTS
1.0 INTRODUCTION ..................................................................................................5
1.1 Purpose of this guide .................................................................................5
1.2 Typical D-100 Network Interface Module .................................................5
1.3 Standard Features and Specications .......................................................5
1.4 Additional Hardware Required ................................................................. 7
1.5 Working Environment ...............................................................................7
1.6 Warranty & Serial Number ........................................................................7
2.0 UNPACKING ......................................................................................................... 7
2.1 Checking that you have received everything ............................................7
3.0 INSTALLATION ....................................................................................................8
3.1 Site Selection .............................................................................................8
3.2 Mechanical Installation .............................................................................9
3.3 Electrical Installation ...............................................................................10
3.3.1 Input Signal Connections from Flow Meter ................................10
3.3.1.1 ONICON Turbine Flow Meters ........................................ 11
3.3.1.2 ONICON F-3500 Flow Meters .........................................12
3.3.1.3 ONICON F-3100 and F-3200 Flow Meters ...................... 13
3.3.1.4 ONICON F-2500 Flow Meters .........................................14
3.3.1.5 ONICON F-5100 Series Flow Meters ..............................15
3.3.1.6 ONICON F-5200 Series Flow Meters ..............................16
3.3.2 Average Frequency (Pulse) Flow Input ........................................17
3.3.3 Analog Input (Flow) ......................................................................17
3.3.4 Directional Contacts ......................................................................17
3.3.5 Auxiliary Rate Inputs ....................................................................17
3.3.6 Auxiliary Pulse Input ...................................................................17
3.3.7 Totalizer Outputs and Mode Status ..............................................20
3.3.8 Isolated Analog Outputs ...............................................................20
3.3.9 Input Power ................................................................................... 21
4.0 D-100 START-UP AND COMMISSIONING .......................................................23
4.1 Display and Keypad .................................................................................23
4.2 Processor Start-up .................................................................................... 23
4.3 Units and Multipliers ..............................................................................24
4.4 Analog Outputs ........................................................................................ 24
4.5 Enabling / Disabling Front Panel Reset ..................................................24
4.6 Commissioning ........................................................................................25
5.0 DIAGNOSTICS ....................................................................................................27
5.1 Diagnostics ...............................................................................................27
5.1.1 Diagnostic Lights ...........................................................................27
5.1.2 Flow Test Signals ..........................................................................27
5.1.3 Ai3 & Ai4 Test Signals ..................................................................27
5.2 Troubleshooting .......................................................................................28