Section 03 TROUBLESHOOTING
Subsection 01 (TROUBLESHOOTING CHART)
WARNING LIGHT IS ON/ENGINE NOT RUNNING
OTHER OBSERVATION POSSIBLE CAUSE REMEDY
Beeper signal (4 short
beeps every 3 seconds)
Safety lanyard on DESS post Remove safety lanyard from DESS post
STEERING POLE IS HEAVIER THAN USUAL
OTHER OBSERVATION POSSIBLE CAUSE REMEDY
Steering pole return spring adjustment
Adjust
Broken steering pole return spring) Replace
STEERING POLE IS STIFFER THAN USUAL
OTHER OBSERVATION POSSIBLE CAUSE REMEDY
Dirty/damage parts
Inspect/clean/replace mounting bridge,
clamps, tube and spring guide
ENGINE CANNOT REACH MAXIMUM RPM (LACK OF PERFORMANCE)
OTHER OBSERVATION POSSIBLE CAUSE REMEDY
Increased exhaust
noise/smoke in bilge
Broken expansion pipe
Inspect/replace. Refer to EXHAUST
SYSTEM
Water inside expansion
pipe
Broken expansion pipe (water jacket)
Inspect/replace. Refer to EXHAUST
SYSTEM
Melted exhaust
hose/fitting
Exhaust restriction or external water leak
from exhaust cooling system
Inspect/repair
10 smr2004-3D
To Next Page
Loading...
Need help?
General