EEvveerryy ttwweellvvee mmoonntthhss
CChheecckk RRoouuttiinnee
Battery Replace if lifting is sluggish
All parts Check and replace any worn parts, including arm covers,
arm wear pads, trolley top and side covers, cot release
handle springs, anchor lever cover, anchor inductive
primary cover, transfer lock plate, transfer lock pin, or cot
guides, if necessary
NNoottee -- The transfer lock plate (639000010260) is only
compatible with PPoowweerr--LLOOAADD units manufactured after
July 31, 2017 or units that have been previously serviced
with the 639007000021 kit. Check the product serial
number tag to confirm date of manufacture.
Dead stop bumpers Replace if the corner is damaged
Motor Replace when no motor motion exists
Cylinder rod end Replace if PPoowweerr--LLOOAADD functions in manual mode and
the error LED is illuminated
Full functionality See
Installation checklist
in the Operations Manual
Hydraulic Check for hydraulic leaks
Transfer lock bearing Replace once per year
NNoottee -- During bearing replacement, make sure that the
surrounding area is clean (anchor) and apply molybdenum
disulfide grease to the transfer lock pin.
V-guide rollers If the product is difficult to roll or wear is noticeable in the
transfer roller channel beyond the inner rod, replace the V-
guide rollers on the trolley and switch the patient right,
outside, bottom transfer rod with the patient right, outside
top transfer rod. Check all remaining rollers for damage or
excessive wear. Replace, if necessary.
Lift arm springs Replace the lift arm springs (0038-895-000) that are
located under the trolley top cover
FFllaatt rroolllleerr aanndd VV--gguuiiddee ppaarrtt rreeppllaacceemmeenntt sscchheedduullee
You must replace the flat roller and V-guide parts every 14,110 calls. This is to make sure that the PPoowweerr--LLOOAADD remains
functional. Follow this call volume time table to remain compliant with this requirement. The time table will also help plan
appropriate service intervals.
CCaallllss ppeerr ddaayy MMoonntthhss
6 80
7-8 60
9-10 48
11-12 40
13 36
14-15 30
EN 52 6390-709-001 Rev AB.1
To Next Page
Loading...
Need help?
General
