WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For Safety PARTS MANUAL
Copyright © 2007 Terramite Corporation
Table of Contents
SECTION ONE: INTRODUCTION/INFORMATION
History of Terramite Backhoes .................................................................................. 1.1
Before You Start ......................................................................................................... 1.2
Safety Tips .................................................................................................................. 1.2
Hand Signals .............................................................................................................. 1.3
Call First ..................................................................................................................... 1.4
SECTION TWO: PARTS
Left or Right is Determined from the Operator’s Position ...................................... 2.1
View of Front Loader Bucket .................................................................................... 2.2
View of Right Side of Loader Bucket ....................................................................... 2.3
View of Underside of Arm Center .............................................................................. 2.4
View of Right Side of Arm Assembly ...................................................................... 2.5
View of Front Axle
(Bumper Not Shown) ................................................................................. 2.6
View of Front Axle
(continued) ................................................................................................ 2.7
View of Front Axle - Ball Socket Style (Bumper Not Shown) ............................................ 2.8
View of Hub Assembly and Spindle ......................................................................... 2.9
View of Right Front Tire and Rim .......................................................................... 2.10
View of Right Side of Tractor ................................................................................. 2.11
View of Left Side of Tractor .................................................................................... 2.12
View form Right Side of Diesel Engine Compartment
(Without Air Filter) ................ 2.13
View of Diesel Air Filter Assembly ........................................................................ 2.14
View of Muffler Assembly - Diesel ......................................................................... 2.15
View Left Side of Kubota Engine ............................................................................ 2.16
View Right Side of Kohler Engine ......................................................................... 2.17
View of Kohler Engine Leftside .............................................................................. 2.18
View of Power Steering Gear ................................................................................... 2.19
View of Front Valve w/Fittings .............................................................................. 2.20
View of Loader Valve Assembly and Battery - Perkins ......................................... 2.21
View of Front Valve Linkage System .................................................................... 2.22
View of Left Side of Diesel Dash Wiring Harness - Perkins ................................. 2.23
View of Right Side of Diesel Dash Wiring Harness -Perkins ............................... 2.24
View of Operator Position Facing Dash (Diesel) ................................................... 2.25
View of Operator Position Facing Dash (Gas) ....................................................... 2.26
View of Transmission Assembly (Diesel) .............................................................. 2.27
View of Transmission Assembly (Gas) .................................................................. 2.28
View from Right of Foot Pedal Control ................................................................. 2.29
View from Right Side of Hydraulic Tank ............................................................... 2.30
View from Left Side of Fuel Tank ........................................................................... 2.31
View of Hydraulic Filter Assembly ........................................................................ 2.32
View from Back of Seat ........................................................................................... 2.33
View from Operator Position of Rear Valve
(Straight Boom) ......................................... 2.34
View from Operator Position of Rear Valve
(Straight Boom) ......................................... 2.35
View from Operator Position of Rear Valve (Prior to 1-1-01) ......................................... 2.36
View from Operator Position of Rear Valve
(Curved Boom Prior to 1-1-01) ................... 2.37
View from Operator Position of Backhoe Valve
(Curved Boom Prior to 1-1-01) ............................ 2.38
View from Operator Position of Rear Valve (Prior to 1-1-01) ..................................... 2.39
View from Operator Position of Rear Valve
(180 Swing) ............................................... 2.40
View of Fitting Location for Rear Valve
(180 Swing) ..................................................... 2.41
View of Hose Location for Rear Valve (180 Swing) ......................................................... 2.42
View of Right Rear Tire and Rim ............................................................................ 2.43
View from Front of Rear Axle ................................................................................. 2.44
Top View of Parking Brake Assembly .................................................................... 2.45
View from Left Side of Outrigger Assembly
(Curved Boom) ........................................ 2.46
View from Left Side of Swing Assembly
(Curved Boom Prior to 1-1-01) ........................ 2.47
View of Backhoe Assembly for T5D with Straight Boom .................................... 2.48
View from Right Side of Swing Assembly
(Straight Boom) .......................................... 2.49
View of Left Side of Backhoe Assembly
(Prior to 1-1-01) ............................................... 2.50
View of Left Side of Rear Bucket & Linkage Assembly ....................................... 2.51
T7 Backhoe Assembly 180 Degree ......................................................................... 2.52
T7 Backhoe Assembly 180 Degree
(continued) ................................................................ 2.53
Tooth Caps ................................................................................................................ 2.54
Position to Check Proper Lever in Hydraulic Tank ............................................... 2.55
CONTENTS
SECTION THREE: DECALS
Decal Location - Front Arms ....................................................................................... 3.1
Decal Location - Side View ......................................................................................... 3.2
Decal Location - Dash .................................................................................................. 3.3
Decal Location - Dash
(continued) ............................................................................................ 3.4
Decal Location - Right Fender .................................................................................... 3.5
Decal Location - Left Fender ....................................................................................... 3.6
Decal Location - Side View
(continued) .................................................................................. 3.7
Decal Location - Rear Valve ........................................................................................ 3.8
Decal Location - Rear Valve
(continued) .................................................................................. 3.9
SECTION FOUR: COMPONENTS
T5D/T7 Pin Chart
(Straight Boom) ............................................................................................. 4.1
T5D/T7 Pin Chart
(Straight Boom) ............................................................................................. 4.2
T7 Pin Chart
(Curved Boom Prior 1-1-01) ........................................................................... 4.3
T7 Pin Chart (Curved Boom Prior 1-1-01) .................................................................................... 4.4
T7 Pin Chart
(180 Degree Boom) ................................................................................................. 4.5
T7 Pin Chart
(180 Degree Boom) ................................................................................................. 4.6
Wiring Diagram Kohler Command 20HP/25HP ....................................................... 4.7
Wiring Diagram Perkins Diesel 20HP ....................................................................... 4.8
Wiring Diagram Perkins Terminals ............................................................................ 4.9
Wiring Diagram for Perkins Diesel Dash Harness .................................................. 4.10
Wiring Diagram for Perkins Diesel Dash Harness
(continued) ...................................... 4.11
Wiring Diagram for Perkins Diesel Dash Harness
(continued) ...................................... 4.12
Wiring Diagram for Perkins Diesel Dash Harness (continued) ...................................... 4.13
Wiring Diagram Kubota ........................................................................................... 4.14
Wiring Diagram Kubota
(continued) ..................................................................................... 4.15
Glow Plug Timer Relay ............................................................................................ 4.16
Hose and Fitting Location for V10 Valve
(180 Degree Swing) .......................................... 4.17
View from Operator's Position for V10 Valve
(180 Degree Swing) .................................. 4.18
Valve Section Service Kits V10 ............................................................................... 4.19
Valve Section Kits V10
(continued) ....................................................................................... 4.20
Valve Section Kits V10
(continued) ....................................................................................... 4.21
Valve Section Kits V10
(continued) ....................................................................................... 4.22
Valve Section Service Kits V10 (continued) ........................................................................ 4.23
Valve Section Service Kits V10
(continued) ........................................................................ 4.24
Hydrastatic Transmission ......................................................................................... 4.25
Hydrastatic Transmission
(continued) .................................................................................. 4.26
Sunstrand Transmission ........................................................................................... 4.27
Sunstrand Transmission
(continued) ..................................................................................... 4.28
Gear Pump Part Number 66000 Gas / 66001 Diesel ............................................... 4.29
MAB/MAE Torquemotor Exploded Assembly View ............................................ 4.30
Rear Axle Assembly .................................................................................................. 4.31
Rear Axle Assembly
(continued) ............................................................................................. 4.32
Schematic View of Typical Control Valve Assembly - V20 .................................. 4.33
General Tightening Toque for Bolts, Nuts and Taperlock Studs - V20 ................. 4.34
4 Way, 3 Position Valve Section - V20 .................................................................... 4.35
Load Check Plug Assembly - V20 ........................................................................... 4.36
Model J-HP High Pressure Relief - V20 ................................................................. 4.37
SPK Monoblock Valve ............................................................................................. 4.38
Cylinder Components .............................................................................................. 4.39
T7 Loader Hydraulic Circuit Hose Lengths
(in.) ............................................................. 4.40
T7 Rear Boom Hose Diagram V10 .......................................................................... 4.41
T7/T9 Sunstrand Diesel Hose Diagram with Oil Cooler ....................................... 4.42
SECTION FIVE: OPTIONS
Quick Attach Backhoe Buckets ................................................................................... 5.1
View of Clam Shell 4 in 1 Bucket
(Factory Installed Option) .................................................. 5.2
View of Clam Shell 4 in 1 Bucket from Drivers Position (Factory Installed Option) ..........................
5.3
View Under the Dash for Clam Shell 4 in 1 Bucket (Only as Factory Installed Option) .........................
5.4
SECTION SIX: TRANSLATIONS
Translations ....................................................................................................... 6.1 to 6.6
SECTION SEVEN: INDEX
Index .................................................................................................................. 7.1 to 7.5
Sample: Limited New Product Warranty ................................................................... 7.6
To Next Page
Loading...