VAF instruments OILCON MARK 6M - Page 153

VAF instruments OILCON MARK 6M

175 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

152

Drawing 26 – 0806-8035

Table of Contents

Default Chapter2
- Table of Contents2
1 Preface7
- General7
- Symbols8
- Copyright8
2 Product Description9
- Principle of Operation9
- Product Configuration10
- Sampling System Arrangements13
3 Technical Specification15
- General15
- Main Control Unit (MCU)15
- Electro Pneumatic Unit (EPU)16
- Skid17
- Sample Pump17
- Reference Table of Products Which May be Measured18
- Biofuel Guidelines and Definitions19
4 Safety Instructions20
- Safety Precautions20
5 Unpacking21
6 Installation23
- Introduction23
- Utilities23
- Pipework General24
- Bulkhead Penetrations General30
- Electrical Installation General32
  - Electro Pneumatic Unit (EPU)32
  - Starter Box33
- Control Room Equipment - Main Control Unit (MCU)33
  - Speed Input33
  - Overboard Valve Control33
- Installation Checklist34
- Overview Installation Check38
7 Operating Instructions44
- Layout of the MCU44
- Operating the MCU and Menu Layout46
  - Standby Mode (Menu 1)48
- Short Reference Guide for Operating the MCU66
  - Discharging Ballast Water66
  - Shutdown of Discharging Operations68
- Miscellaneous69
  - Oil Content Reading Higher than Expected69
  - Oil Level Alarm69
- Operational Alarms70
- System Failures71
  - Auto/Manual Operation71
- System Overrides73
8 Maintenance75
- Maintenance General75
- Routine Maintenance76
- Test and Check-Out Procedure78
9 Repair or Replacement85
- Detector Cell85
  - Removing the Detector Cell85
  - Reinstalling the Detector Cell85
- Window Wash Pump86
- Sample Pump87
  - Disassembling the Pump/Motor87
  - Reassembling the Pump/Motor88
- Differential Pressure Transmitter - FUJI89
  - Zero Adjustment of DPT - FUJI89
  - Span Adjustment of DPT - FUJI89
- Differential Pressure Transmitter - ABB90
  - Zero Adjustment of DPT - ABB90
  - Span Adjustment of DPT - ABB90
14 Disposal91
10 Take out of Service91
11 Removal and Storage of Equipment91
12 Malfunction and Send for Repair91
13 Environment91
15 Trouble Shooting and Fault Finding92
- Introduction Fault Finding Guide92
- Fault Finding Guide93
- Calibration Alarms95
  - Zero Error Alarm95
  - Path Dirty Alarm96
- System Alarms97
- GPS Problems99
  - No GPS Signal Visible99
- Power Supply Problems100
  - MCU Power Failure100
  - Electro Pneumatic Unit Power Failure100
- Air Supply Problems101
  - Air Supply Failure101
  - Water Found in the Monitors of the Air System101
- Solenoid Valve Problems101
  - Valve Not Working101
- Pneumatic Valve Problems102
- Window Wash Pump Problems103
- Sample Pump Problems104
  - Electrical Problems104
    - Pump Runs but the Green Indicator on the Starter Box Is off104
    - Pump Should be Running but Is off104
  - Pump Related Problems104
    - No Flow105
- Differential Pressure Transmitter Problems106
- Fault Finding Form107
16 Certificates111
- Certificates of Ex-Proof111
- Certificates of Type Approval126
17 Drawings127
18 Abbreviations169
19 Spare Parts170
20 Warranty Conditions172