Alde Compact 3010 - Heating System Maintenance; How the Alde Heater Works

3
US/CAN
Consumer safety information 2
Safety warnings 2
Intended use 3
Prohibited use 3
Safety features 3
Operating instructions boiler
4
 Descriptionoftheheatingsystem 4
 HeatingwithLPGas 5
 Heatingwithelectricity 5
 Theprincipleofconvection 5
 Usingtheboiler 6
 Storageandwinterization 7
 Maintainingtheheatingsystem 7
 LPGasconnectionsandhoses 7
 Glycolheatinguid 7
 Fillingthesystemwithglycoluid 8
 Bleedingtheheatingsystem 8
 Troubleshooting 9
 Importantinformation 9
Operating instructions
Control Panel 3010 614 10
ServiceandReset 15
Faultmessages 16
 EmergencyStart 16
Operating instructions
Control Panel 3010 214 17
Installation instructions boiler 18
 Technicaldata 18
ApplicationTrackinglabel
18
 Installingtheboiler 18
 MountingtheWallue 19
 MountingtheInlet/Exhausthose 19
 MountingtheExpansiontank 19
 Connectiontotheheatingsystem 20
 ConnectiontotheFresh-watersystem 20
 Safetyvalvewithdrain 20
 ConnectingtheLPGas 20
 Theelectricalconnection 21
 Fillingtheheatingsystem 21
 Inspectingtheheatingsystem 21
Installation instructions
Control Panel 3010 614 22
Installation instructions
Control Panel 3010 214 23
Schematic Wiring diagram boiler 24
Wiring diagram boiler 25
Warranty Product Registration 26
Warranty Statement 27
Theseinstructionsexplaintheinstallation/assemblyand
operationoftheboiler,controlpanelandexpansiontank.
Theseinstructionsareapprovedfor
TheAldeCompact3010boilerttedin
recreationalvehicles.
Installationandrepairsmayonlybecarriedoutbya
professional.Thisboilermustbeinstalledinaccordance
withlocalcodesifany;ifnot,followANSIZ223.1/NFPA
54orCAN/CSAB149.1,NaturalGasandPropane
InstallationCode,asapplicable.
California Proposition 65listschemicalsubstancesknowntothestatetocausecancer,birthdefects,death,
seriousillnessorotherreproductiveharm.Thisproductmaycontainsuchsubstances,betheiroriginfromfuelcom-
bustion(gas)orcomponentsoftheproductitself.
Thisboilerisequippedwiththefollowingsafetydevices:
Flame monitoring
Iftheamegoesoutthegassupplyisswitchedoffbya
amemonitoringdevice.
Low-voltage shutdown
Ifvoltagedropsbelow10.5VDC,thegassupplytothe
burnerwillbeswitchedoff.
Monitoring of the exhaust fanIfthereisafailureofthe
exhaustgasfan,thegassupplytotheburnerisswitched
off.
Monitoring of hot water temperature
Awaterovertemperatureswitchavoidsexcessivelyhigh
watertemperaturesabove185°F(85°C).
TABLE OF CONTENTS
PROHIBITED USE
Tobeusedinrecreationalvehiclesandnootherplaces.
INTENDED USE
SAFETY FEATURES